SUZUKI Complaints

WHILE TRAVELING APPX 30 MPH AND APPROACHING A TURN I APPLIED THE BRAKES FRONT AND REAR. THE FRONT BRAKE FAILED. I EXAMINED THE CABLE, MASTER CYLINDER AND BRAKE LINE AND FOUND NO PROBLEMS OR LEAKS. MASTER CYLINDER WAS FULL. I CONTACTED THE LOCAL SUZUKI MCY DEALER TO SEE IF THEY HAD SIMILAR PROBLEMS AND WAS ADVISED THEY HAVE. THEY BELIEVE A COMPLETE BRAKE FLUID FLUSH AND WRAPPING THE BLEEDER SCREW WITH TEFLON TAPE THEN THE SYSTEM IS REFILLED. THEY FURTHER ADVISED THIS HAPPENS ON BIKES THAT ARE NOT DRIVEN DAILY AND THE BLEEDER SCREW ALLOWS AIR TO ENTER THE BRAKE SYSTEM THIS CLEARLY PRESENTS A DANGEROUS SAFETY HAZARD ESPECIALLY ON A MOTORCYCLE. *JS

WHILE DRIVING 70 MPH ON THE HIGHWAY IN HEAVY TRAFFIC TO A SCHEDULED DOCTORS APPOINTMENT FROM TOLEDO, OHIO TO ANN ARBOR, MICHIGAN, THE POWER STEERING WHEEL BECAME STIFF AND DIFFICULT TO CONTROL AND OPERATE THE VEHICLE PROPERLY AND SAFELY. WHEN CHANGING LANES TO GET OFF THE FREEWAY AFTER DRIVING 56 MILES THE POWER STEERING WHEEL WAS HARD TO TURN WHILE EXITING OFF THE OFFRAMP. I WAS ABLE TO DRIVE TO A NEARBY SERVICE CENTER CALLED GOODYEAR. GOODYEAR ANALYZED THE VEHICLE AND SAID THE DRIVE BELT HAD BROKEN OFF THE AIR COMPRESSOR WHICH CONTROLS THE POWER STEERING BELT. GOODYEAR HAD TO PUT A NEW DRIVE BELT ON, WHICH COST ME $115.89. ADDITIONALLY, GOODYEAR SAID THE A/C COMPRESSOR HAD MALFUNCTIONED AND THAT CAUSED THE A/C COMPRESSOR TO FREEZE UP WHICH CAUSED THE SERIOUS PROBLEM OF THE POWER STEERING BELT TO BREAK OFF. (SHREDDED) GOODYEAR'S ESTIMATE TO REPAIR THE COMPRESSOR MALFUNCTION WAS $1,500.00 DOLLARS. THE ESTIMATE COST OF THE A/C COMPRESSOR PART BY ITSELF FOR THE SUZUKI XL7 03 WAS $600 DOLLARS. ALSO, WHEN I RESEARCHED THE INTERNET FOR OTHER SIMILAR SUZUKI A/C MALFUNCTION COMPLAINTS I FOUND NUMEROUS SUZUKI XL7 OWNERS WHO HAVE COMPLAINED ABOUT THIS PROBLEM, IE., THE A/C COMPRESSOR HAS A SERIOUS HABIT OF FREEZING UP AND BREAKING THE DRIVE BELT! I BELIEVE THAT THIS IS A VERY SERIOUS SAFETY HAZARD FOR OWNERS OF SUZUKI XL7 03 MODELS AND YOUR AGENCY NEEDS TO INVESTIGATE THIS SAFETY DEFECT BEFORE THE SUZUKI XL7 CAUSES A SERIOUS VEHICLE ACCIDENT WHICH COULD RESULT IN DEATH! ADDITIONALLY,ANYTHING THAT WOULD IMPAIR THE OPERATION OF A MAJOR PART OF ANY VEHICLE IS A "SAFETY DEFECT" AND HAZARDOUS!" SUZUKI MANUFACTURERS OUGHT TO BE HELD ACCOUNTABLE FOR THIS SAFETY PROBLEM AS THEY MANUFACTURED THE SUZUKI XL7 03 AND SHOULD HAVE KNOWN THE A/C COMPRESSOR COULD MALFUNCTION WHICH IS THE CAUSE FOR THE DRIVE BELT TO BREAK OFF THE POWER STEERING. *JS

DASH LIGHTS WENT OUT IN CAR. CHECKED FUSE AND NO BAD FUSE. WENT TO DRIVE THE CAR AND THEN NOTICED HAD NO BREAK LIGHTS, HEAD LIGHTS, AND WINDOWS DID NOT ROLL DOWN. I HAD HIGH BEAMS IF I WANTED TO DRIVE IT WHILE HOLDING THE LIGHT SWITCH FOR THE HIGH BEAMS.HAD ALL FUSES CHECKED, AND WAS THEN TOLD IT WAS IN THE WIRING!!! CAR HAD BEEN IN THE SHOP BEFORE FOR TRANSMISSION RANGE SENSORS. IT SEEMS TO BE ONE ISSUE AFTER ANOTHER WITH THIS CAR ALL OF A SUDDEN. TIRE PRESSURE LIGHT COME ON FOR A FEW DAYS THEN GOES OUT FOR A FEW, AND THAT IS WITH NEW TIRES. NOT VERY HAPPY WITH THIS CAR AT ALL.. *JS

WE HAVE HAD SEVERE HEADLIGHT ISSUES WITH THIS 2006 SUZUKI GRAND VITARA SINCE WE PURCHASED IT. THE WIRING HARNESS FOR THE HEADLIGHTS CONTINUE TO MELT EVEN AFTER BEING REPLACED 3 TIMES! THE DEALERSHIP OR SUZUKI MOTORS HAVE BEEN OF ANY HELP AND OFFER ZERO ASSISTANCE WITH THE PROBLEM. A QUICK SEARCH ONLINE OF GRAND VITARA HEADLIGHT ISSUES WILL GET THOUSANDS OF RESULTS. I AM CONFIDENT THAT SUZUKI IS WELL AWARE OF THIS ISSUE, BUT SIMPLY REFUSES TO ISSUE A RECALL NOTICE BECAUSE IT WILL COST THEM MANY MILLIONS OF DOLLARS IN REPAIRS. MY HEADLIGHT CAUGHT FIRE DRIVING DOWN THE INTERSTATE AND I COULD HAVE BEEN KILLED DUE TO THEIR FAULTY EQUIPMENT. THIS IS A PROBLEM THAT A GOV'T AGENCY NEEDS TO MAKE SUZUKI FIX. THIS COULD CAUSE ACCIDENTS AND COULD BE FATAL IF HEADLIGHTS ARE BURSTING IN TO FLAMES. I SUGGEST ANYONE WHO HAS HEADLIGHT HARNESS SOCKETS THAT ARE MELTING...NOT DRIVE THE VEHICLE! IT CAN AND WILL CATCH ON FIRE!!! *JS

TL* THE CONTACT OWNS A 2009 SUZUKI SX4. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR A ROUTINE OIL CHANGE. TWO WEEKS LATER, THE AIR BAG AND TIRE PRESSURE WARNING LIGHTS WERE ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THEY ADVISED THAT THE SENSORS NEEDED TO BE REPLACED FOR BOTH COMPONENTS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 62,000 AND THE CURRENT MILEAGE WAS 63,419.

TL* THE CONTACT OWNS A 2011 SUZUKI SX4. THE CONTACT STATED THERE WAS A CRACK ON THE SIDE OF THE VALVE STEM THAT CAUSED A SLOW LEAK IN THE TIRE. THE VEHICLE WAS REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30000.

THIS IS THE 3RD TIME MY VOLTAGE REGULATOR/RECTIFIER HAS GONE OUT. GONE TROUGH 6 BATTERIES IN PAST 10 MONTHS. BIKE STALLED UNEXPECTEDLY FELL OVER AND PINNED MY LEG AGAINST MY RIDING FRIENDS BIKE SCRATCHED MOTOR AND THEN HAD TO BE TOWED HOME. *TR

I WAS DRIVING EARLY IN THE EVENING AND DRIVING IN A WELL LIT 15 MPH ZONE JUST AFTER DUSK. PEOPLE ON THE SIDEWALK STARTED POINTING AT MY CAR. WHEN I TURNED UP THE SIDE STREET I REALIZED I HAD NO HEADLIGHTS! I FOUND OUT THAT MY HIGH BEAMS STILL WORKED AND I DROVE A SHORT DISTANCE WITH THE HIGH BEAMS. I HAD THE CAR CHECKED FOR FUSES, RELAYS, AND BULBS BY MY MECHANIC. I WAS TOLD IT WAS IN THE WIRING. I CAME HOME AND CHECKED THE COMPUTER AND FOUND OUT THAT THERE WAS A RECALL FOR THIS PROBLEM WHICH I WAS NEVER INFORMED OF. THIS COULD HAVE RESULTED IN A POTENTIAL CRASH! THE AMERICAN SUZUKI COMPANY WILL NOT HONOR THIS RECALL. THIS CAR WAS NOT SOLD IN HAWAII, BUT WAS SHIPPED HERE FROM CALIFORNIA FROM THE PERSON I BOUGHT IT FROM IN 2005. NOW THEY WANT ME TO PAY FOR IT, AND I HAVE TO FIND MY OWN ASE MECHANIC THAT IS WILLING TO HAVE INSTRUCTIONS FAXED TO THEM IF THEY MEET THE REQUIREMENTS.. ON TOP OF THAT, THEY ARE ONLY WILLING TO PAY $68.00....WHICH I AM SURE WILL NOT COVER THE LABOR FOR THIS PROCEDURE. I AM ON SOCIAL SECURITY AND DO NOT HAVE THE MONEY TO PAY FOR THIS REPAIR.. WHAT DO I DO NEXT? I NEED MY HEADLIGHTS FIXED! PLEASE HELP! *TR

TL* THE CONTACT OWNS A 2000 SUZUKI ESTEEM. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE INSPECTED, SHE WAS NOTIFIED THAT THE SUB FRAME WAS CORRODED. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT THE SUB FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 125,000.

INFERIOR STEERING HEAD BEARING ISSUE. FOR A 2006 SUZUKI BOULEVARD C90T (VL1500T). ON DECELERATION BETWEEN 40-35 MPH, THE HANDLE BAR CONSISTENTLY SHAKES VIOLENTLY FROM SIDE TO SIDE. APPEARS TO BE FAILURE OF OEM BALL BEARINGS. NEEDS NEW TAPERED ROLLER BEARINGS TO CURE THIS DANGEROUS CONDITION. THIS WILL BE A SIGNIFICANT COST TO REMOVE AND REPAIR THE STEERING HEAD BEARINGS ($35 FOR BEARINGS AND $250 DEALER LABOR). THE DEALER STATES AS WELL AS SUZUKI AMERICA, THAT "THIS WOBBLE CONDITION IS A CHARACTERISTIC OF THE BIKE". I PURCHASED THIS USED MOTORCYCLE ON 03/31/2012. THE BIKE HAD 4899 MILES ON IT AT THE TIME OF PURCHASE. THE WOBBLE WAS NOTICED ALMOST IMMEDIATELY AFTER PURCHASE. THE DEALER WOULD ONLY AGREE TO TIGHTEN THE STEERING HEAD BEARINGS, WHICH IN TURN ONLY SLIGHTLY HELPED THE SEVERE WOBBLE ISSUE. DEALER ADVISED OF NO CUPPING OR WEAR PROBLEMS WITH THE TIRES. *TR