2022 TESLA MODEL X Complaints

The electric power assist steering system on my 2022 Tesla Model X began displaying a "Steering Assist Reduced / Steering May Require Increased Effort" warning intermittently beginning in approximately May 2024, shortly after I purchased the vehicle. This warning appeared more times than I can count over the following months. In most instances the warning appeared but the steering continued to function normally. On approximately March 2, 2026, the warning appeared and for the first time the steering became extremely difficult to turn, requiring significantly increased physical effort to control the vehicle. The first physical failure occurred while parking at low speed in reverse. The steering failure also occurred subsequently while driving at highway speeds. In both instances I stopped the vehicle, exited, waited briefly, and upon re-entering the vehicle the warning cleared and steering returned to normal. This same sequence repeated the following day. The vehicle was brought to a Tesla authorized service center on March 13, 2026. Tesla's technician confirmed the steering assist reduction as reported and determined the steering gear required full replacement. The failed part, steering gear left hand drive part number 1070801-00-F, was replaced. Only full hardware replacement resolved the issue permanently. Prior power cycling provided only temporary relief. My safety was directly at risk. I am a full-time rideshare driver operating at highway speeds. The failed component has been replaced and is in Tesla's possession. Tesla is charging the full repair cost out of pocket despite this matching a documented pattern of identical failures reported to NHTSA by multiple Tesla owners.

While driving my 2022 Tesla Model X at highway speed, I experienced a sudden loss of steering assist shortly after Supercharging. The steering wheel became extremely difficult to turn, and I had to use significant force to maintain control. The vehicle displayed a ‘Steering Assist Reduced’ alert, FSD became unavailable, and the suspension behaved unexpectedly. After the incident, the vehicle was taken to Tesla service. At this time, I have not received a clear explanation of the root cause of the steering-assist loss. Because this event occurred at highway speed and created a safety concern, I am submitting this report so the incident can be documented and reviewed.

On January 31, 2026, at 10:30 PM, I was driving from Fort Lauderdale to my home in Boca Raton, Florida. I was using FSD supervised mode. Close to my home, a big red image suddenly appeared, the car started accelerating fast, and I had no control over the car or its steering wheel. The car hit several electrical posts and only stopped after the airbags engaged. My wife was in the passenger seat. The front of the car was totally damaged, and I will have to total it.

I am writing to formally document a life-threatening mechanical failure involving my 2022 Model X on January 30, 2026. While my wife was operating the vehicle, it suffered a simultaneous and catastrophic collapse of all primary safety systems. During operation, the vehicle experienced a total loss of steering and braking control. This was accompanied by a rapid cascade of critical system alerts on the primary display, including “ABS Malfunction,” “Stability Control Disabled,” and “Steering Assist Reduced/Disabled.” Most critically, the vehicle exhibited Sudden Unintended Acceleration (SUA), increasing speed in direct opposition to the driver’s physical application of the brake pedal. This resulted in a near-miss where the driver narrowly avoided a construction crew.

The turn signal buttons intermittently fail to work. Many presses of the tuen signal buttons do nothing. When it stops working it stops for several minutes and then will start to work again. The problem is happening more and more frequently. The yoke has been replaced 3 times already for the same issue and after about a year just started happening again.

Both front half shafts failed. I did research and this part is known to be substandard, was recalled in China, and remains a problem in the US.

My 2022 Tesla Model X has two recurring safety-critical defects that remain unresolved despite multiple repair attempts. 1. Airbag / Restraint System Failure (RCM2 / OCS Defect): The vehicle frequently misclassifies the front passenger seat. It shows a passenger when the seat is empty and activates passenger seatbelt warnings incorrectly. Recently the vehicle displayed: “Front passenger safety restraint system issue: Service required (RCM2_a064).” Tesla attempted to repair an electrical harness in the seat, but the problem returned. A Tesla technician documented that the seat may still need a new occupancy sensor. Because this affects the Occupant Classification System and airbag deployment logic, it raises potential FMVSS 208 compliance concerns. 2. FSD / GPS Safety Hazard (5 Unsuccessful Repair Attempts): Across five service visits, Tesla attempted to fix GPS drift and unsafe FSD routing. The vehicle still attempts incorrect turns, performs premature lane changes, and misinterprets intersections. One recent incident involved FSD attempting a left turn one intersection early, nearly causing a collision. Tesla replaced the GPS antenna, recalibrated cameras, and replaced the computer, but the unsafe behavior continues. These two defects—incorrect airbag/OCS behavior and hazardous automated-driving/navigation behavior—create a significant safety risk to occupants and other drivers. Both defects persist after repair attempts. I can provide service records, videos, and documentation upon request.

The vehicle presents a compounded safety defect creating a risk of passenger entrapment and high-voltage fire. 1. High Voltage Manufacturing Defect: On September 3, 2024, authorized Tesla Service technicians diagnosed a critical safety fault. The service record states technicians 'found A/C compressor HV harness was incorrectly routed, rubbing against the steering column' and 'found sand inside the connector'. Tesla repaired this defects under the 'Basic Vehicle Limited Warranty,' confirming it was a factory assembly error. This defect created an imminent risk of a high-voltage short to the steering column, which could result in driver electrocution or total vehicle power loss at speed. 2. Passenger Entrapment: The vehicle has a documented history of Rear Falcon Wing Door failure (7 repair attempts from April 2023 to May 2025). The doors frequently fail to latch or open. On July 8, 2025, the Left Rear Door failed to open due to a sensor fault. 3. Combined Hazard: If the incorrectly routed High Voltage harness causes a vehicle power failure, the rear doors' electronic latches will fail. Because the doors have a history of mechanical jamming, passengers in the rear seats would be trapped in a vehicle with a compromised High Voltage system.

I had my two Teslas parked in the garage. The model X was charging at about 1:30 AM. We heard explosions coming out of the garage. Went to check only to see my model X in flames. We evacuated and called 911 eventually a fire investigation report was made Showing the fire started within the vehicle outward. The battery pack was on fire. We had lithium contamination all over the house and this fire endangered five lives. This incident has been two years ago and until now Tesla refuses to acknowledge the faulty battery and is refusing to do anything about it

The wing-style door of the car closed while my 1-year-old daughter's leg was sticking out. It dragged her leg sideways as it closed, and he femur broke. None of the sensors worked, the door should have detected motion or pressure, but they did not and it resulted in my daughter's leg breaking.