2022 TESLA MODEL X Complaints

I own a 2022 Tesla Model X. I began noticing a creaking/clicking noise from the front steering/suspension area, particularly when turning the steering wheel at larger angles and at low speeds. I brought the vehicle to a Tesla Service Center for inspection. Tesla inspected the vehicle and diagnosed a bent steering rack/steering component. Tesla recommended replacement of the complete steering gear assembly, along with repairs to front suspension components. Tesla provided photographs of the condition and stated in writing that bending this component would require approximately 4,000 to 6,000 pounds of force at a specific angle. Tesla attributed the condition to an external impact. However, I am not aware of any accident, collision, curb strike, significant pothole impact, road-debris strike, or other event that would explain this condition. There were no crash-related warning messages or known impact events preceding the steering symptoms. The first symptom I noticed was the creaking/clicking noise during low-speed steering. I am concerned because the steering system is safety-critical and I do not know when, how, or why the steering component became bent. A damaged or bent steering component could potentially affect steering control, alignment, or vehicle handling if the condition progresses. Tesla has physically inspected the vehicle and confirmed the condition. The recommended steering and suspension repairs have not yet been performed, so the vehicle and the affected components remain available for inspection if requested. I am reporting this because I believe the unexplained deformation/failure of a steering component on a 2022 Model X may represent a potential safety issue, particularly because I am not aware of an external-impact event that would account for the condition.

CRITICAL FLUIDITY/ACCESSIBILITY DEFECT The vehicle lacks a standard mechanical horn assembly, instead it is equipped with a small electronic button. This configuration creates a severe safety hazard due to the following critical failure points: High-Stress Unusability: The button is highly difficult to locate during an unfolding emergency, causing a dangerous delay in driver reaction time. Loss of Function During Maneuvers: When the steering wheel is actively turning, the button's position shifts constantly, making it physically impossible to find or press reliably while evasive steering is underway. Failure to Warn: This design directly compromises the driver's ability to sound an immediate audible warning, drastically increasing the risk of an unavoidable collision.

The power steering fails very often making it hard to turn and happens when I’m on the highway going 60+ mph which is very dangerous and a threat to my safety. The only way to fix it in those moments is to pull over turn the car off which consists of me getting out of my vehicle and waiting two minutes. But usually when it happens once that day it occurs all day even if I reset the car and try all the other troubleshooting options which make it very difficult to rely on the car for safety. It happened only once every few months but now it happens almost every other time I drive my car. This is not a normal wear and tear issue as I’ve had cars before with over 50k miles and not once have I had a power steering failure on those cars which are older and have more mileage.

I was in the car. I had put on my seat belt and reached back to plug in my phone to charge. Before I turned back the phone accelerated forward and crashed into two cars in the parking lot.

I am reporting several safety concerns based on approximately one year of experience using Tesla Full Self-Driving (FSD). Primary Event: Between February 23 and February 28, 2026, while traveling northbound on the NJ Turnpike with FSD engaged, the vehicle accelerated to approximately 95 mph in a 65 mph. The acceleration appeared unexpected and excessive for the traffic conditions. I disengaged FSD and immediately took control of the vehicle to reduce speed and continued driving manually.No collision occurred, but I considered the event a safety risk because the vehicle exceeded the posted speed limit by a substantial margin. Additional Observations: 1. On multiple occasions, FSD appeared not to recognize or comply with “NO TURN ON RED” traffic signs.2. Situations where overhead or elevated traffic signs appeared not to be recognized by the system.3. On one occasion, the vehicle navigated toward railroad tracks where the roadway and tracks intersected at an approximate 45-degree angle. The vehicle behavior caused concern.4. When driving directly into bright sunlight, particularly when the sun is low and shining directly into the windshield, FSD performance appears degraded or confused. Human drivers typically use sun visors and other visual cues in these conditions. The vehicle’s driving behavior appeared less predictable during such events. 5. Lane changes are attempted across areas marked by continuous lane where lane change would not normally be expected. Additional Concern: A significant regulatory issue may involve situations where drivers intervene immediately before a collision. In real-world driving, drivers often instinctively take control when they perceive an imminent hazard. Therefore, when evaluating crashes involving FSD, I believe investigators should review vehicle data for period immediately preceding a collision, including several seconds before any disengagement, rather than focusing solely on whether FSD was engaged at the exact moment of impact.

As I was driving the Tesla Model X, I received a steering assist reduced error on the dash. There was no immediate noticeability, but after about 5 minutes, it felt like there was ZERO power steering, with no additional warnings in the car. With zero power steering, car required extreme forces required to get to the shoulder. If attempting any kind of turn, car would require forces in excess of 80lbs of pressure to execute. Once safely in a parking lot, I put the car into SERVICE mode to check the errors. There was an EPAS error, where it said Torque Sensor 1 not receiving, along with a Torque Sensor 2 not receiving. This has occurred to me 3 times, in the 3 years I've owned the car. Other than "Steering assist reduced", there is no other warning that the car's EPAS steering system reverts to just manual forces required to steer a car. I do not trust my wife to drive this car, as she would not have the strength necessary to get the car to a safe location. If this happened while turning, there's a strong possibility the car would not turn at all, a huge safety factor.

The steering wheel locks periodically and I have to get out and re enter my car. On long drives it works pretty fine and does not do this much on highways only once but in hotter weathers it seems to be much much worse. This happened once before the warranty but I did not think much of it. In one instance the steering wheel was so tight that it hurt my wrist while getting off the road

The primary front trunk (frunk) latch mechanism fails to unlatch on the first attempt, requiring multiple actuations to open. When I brought the vehicle to the manufacturer's official service center to have the defective safety latch inspected and repaired, they confirmed the behavior but refused to fix the underlying hardware. Instead, the service center officially documented on my repair invoice that this latch failure is "frequently present and deemed a characteristic of the vehicle." A malfunctioning, binding, or misaligned front trunk latch poses a severe safety risk. If the primary latch is failing to release properly, it indicates a defect in the retention mechanism that could lead to the hood unexpectedly opening, flying up, and obstructing the driver's vision at highway speeds (a known issue that has caused recalls in the past). The manufacturer's refusal to repair a failing primary safety latch, and instead documenting it as a normal "characteristic," leaves a critical safety component in a compromised and dangerous state. There were no warning lights prior to this failure; it is a physical, mechanical defect that the manufacturer has acknowledged in writing but refuses to remedy.

The failure involves the rear suspension system, specifically suspected rear control arm / suspension linkage play, which caused severe misalignment (rear toe out of specification). The vehicle is available for inspection upon request. This defect created a significant safety risk. The abnormal toe condition caused rapid and uneven tire wear, with both rear tires becoming nearly completely bald within less than 7,000 miles. This condition increases the risk of tire blowout, loss of traction, and potential loss of control at highway speeds. The issue has been confirmed by an independent service center (Les Schwab), which documented suspension play in the rear control arm area and alignment out of specification (rear toe approximately +1.20° total). The alignment could not be maintained, indicating an underlying mechanical issue. Tesla inspected the vehicle but stated that no suspension components required replacement and attributed the issue only to alignment. However, alignment does not go out of specification without a mechanical cause. Despite multiple requests, Tesla refused to provide detailed documentation regarding the inspection or repair of the suspension system. They replaced only one rear tire and did not address the root cause. The other rear tire had already worn completely bald. After approximately 5,386 miles, the replacement tire has again worn down close to the minimum safety limit, demonstrating that the underlying issue was not corrected and continues to affect vehicle safety. There were no warning lights or system messages prior to the failure. The first symptoms were abnormal tire wear, increased energy consumption, and unstable driving behavior at highway speeds, which began shortly after vehicle purchase. This appears to be a repeat safety-related defect that has not been properly diagnosed or repaired.

Lost power steering while I was driving multiple time and I couldn't turn. Later the alert also come on and off but sometime the steering is fine. Found out on Tesla Model X facebook group people are having the same issues.