2024 TOYOTA GRAND HIGHLANDER Complaints

Toyota T-SB-0082-24 / Rotational Clicking Noise From Front Drive Shaft Assembly ( CV JOINT) CV joint defect poses an unreasonable risk to safety, especially if it fails while you are driving. An unreasonable risk is one where the potential for harm is much greater than the potential benefit of taking the risk. Driving with a compromised CV joint fits this definition because it can lead to a complete loss of vehicle control, which can result in a serious accident.

The contact owns a 2024 Toyota Grand Highlander. The contact stated that there was a small crack on the windshield on the driver's side at the top where the windshield meets the frame. The contact stated that the crack had started to expand. The contact recently noticed another crack in the center of the windshield, starting at the bottom. The contact stated that both cracks were approximately 5 inches long and expanding. The contact had not struck a rock or road debris for the windshield to crack. The contact had taken the vehicle to a dealer to be diagnosed and was advised by the dealer that the cracks were the result of small stones being kicked up by other vehicles. The vehicle was not repaired. Additionally, the contact had been experiencing failures of the infotainment screen going black, and the side-view mirror Blind Spot warning lights not functioning as designed. The vehicle had been taken to the same dealer several times, and the dealer resolved the issue. The contact stated that the infotainment screen failure had reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 40,000.

Description of Issue: I have experienced repeated incidents where the accelerator pedal becomes unresponsive (“dead pedal”) after coming to a stop. When pressing the pedal to accelerate, the vehicle does not respond at all for several seconds. Then, without warning, it suddenly surges forward with excessive acceleration once the power engages. This problem happens intermittently throughout a drive each day, often enough to be concerning. It occurs after being stopped at an intersection or in traffic. No warning lights or error messages appear before or during the issue. The delay followed by a sudden surge is dangerous, as I expect the car to move when I press the pedal, but it hesitates instead. When the vehicle finally responds, it accelerates quickly, which could cause me to lose control or collide with another vehicle. Safety Concern: This malfunction creates a significant safety risk. It puts myself, passengers, and other drivers in danger when the vehicle fails to accelerate as expected in high-risk scenarios such as crossing intersections, merging into traffic, or making left turns. The hesitation can leave the vehicle exposed in traffic, and the sudden lurch forward can cause unintended movement or rear-end collisions. Status: The problem has occurred multiple times under similar conditions and is ongoing. It has not yet been inspected or confirmed by a dealer or service center, but I have an apt Aug 24th. However, the malfunction is real, reproducible, and presents a serious hazard that could lead to an accident if not corrected. Many others with the same vehicle have expressed the same concern as well on forums and reported no fix after dealership appointments.

“Apple CarPlay Escape” is not available through software update for this vehicle although other cars of the same model year and 2025 models have this option to quickly navigate between Apple CarPlay screen and Toyota settings screen. As a result, More swipes/touches are needed on the screen to navigate which is unsafe and distracting while driving

I've had consistent issues with the vehicle accelerating and shifting. These include sluggish acceleration, loss of power, sputtering, and limp mode. We've almost been hit by other vehicles almost 10 times because the vehicle has failed to accelerate when pulling into a roadway. The vehicle will start to accelerate slowly, then stop, then 5-10 seconds later will surge forward will the engine revs very high and is delayed shifting into 2nd gear. I've told my Toyota dealership about this numerous times but they keep telling me that there's no issue but there clearly is being that many others are experiencing the same exact problems. There's never been a warning lamp or message when this happens. This is a huge safety issue and my family is extremely lucky that we haven't been involved in a serious accident.

AC condenser has a leak and AC cooling not working-blowing hot air, making vehicle very hot inside. Toyota claiming from road debris damage, front grill not protecting condenser unit enough to allow this not to happen and will not cover under warranty. Seems like a manufacturer grill design problem not consumer. Toyota has no fix to the problem to protect condenser unit from this happening over and over again.

Description of Issue: We have experienced multiple episodes of violent shaking in our 2024 Toyota Grand Highlander while stopped at red lights or in intersections. Both my wife and I have had this happen independently, around two to three times each. Most incidents occurred while our young children were in the vehicle. The most recent incident occurred today, when my wife experienced it twice in a row while stopped at an intersection. Our children were not in the vehicle during today’s event. Component or system involved: UNKNOWN at this time. We suspect a major mechanical or drivetrain-related failure. The entire vehicle shakes violently and feels unstable. We are willing to make the vehicle available for inspection upon request. Safety risk: The severity of the shaking is extreme and it feels as though the car may explode or fall apart. We have had to put the car in park, shut it off immediately, and in some cases, exit the vehicle in the middle of intersections or while stopped at a red light. This places everyone in the vehicle at serious risk, especially our children, and could result in a crash or secondary accident due to the abrupt stop and unexpected behavior in active traffic. Has the problem been reproduced or confirmed by a dealer or service center? The issue has not yet been reproduced by the dealership. We brought the vehicle to Toyota of Escondido after a previous incident. They inspected it but stated they could not find anything wrong. Has the vehicle or component been inspected by others? The vehicle was only inspected by the dealership (Toyota of Escondido). It has not been reviewed by any other parties such as law enforcement or insurance representatives. Warning lamps, messages, or other symptoms prior to the issue: There were no warning lights, error messages, or abnormal behavior prior to the onset of the violent shaking. The issue occurred suddenly each time, without warning.

Sometimes,about 50/50 now, when I stop at a light or a stop sign then try to go, my car refuses to go. Pressing the gas won’t make it go. I just sit there idling or worse, in the middle of oncoming traffic. The lights still work, everything else seems to work. This does this with or without the ac in. It almost jerks you around, but won’t go. This has happened multiple times now.

Ever since I got my car, sometimes it smells like gas on the right side of the vehicle. By driver side and right passenger side in the back. I assumed it was because I topped my gas off, but even when I stopped doing that, it still has a strong gas smell when the car is running and after turning it off. Not ever day, but ever so often.

Numerous times now the vehicle will not accelerate from a stop for about five seconds after the gas is pressed. It always seems to be on hot days with high air conditioner demand.