2006 VOLVO S40 Complaints

TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT THE VEHICLE FAILED TO ACCELERATE MORE THAN 20 MPH AND SEVERAL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

A DESIGN FLAW CAUSED FLOODING WITHIN THE CABIN OF THIS VEHICLE. THE SUNROOF DRAINAGE SYSTEM IS FAULTY AND OVER TIME LEAKS WATER INTO THE FLOOR PAN OF THE CAR, SOMETIMES ENOUGH WHERE FLOODING OCCURS. MY CAR FLOODED A FEW MONTHS BACK SO BADLY UP TO 10 GALLONS OF WATER WAS VACUUMED OUT. THE FLOODING CAUSED DAMAGE TO THE ELECTRICAL HARNESS/CONNECTIONS UNDER THE DRIVER'S/PASSENGER'S SEAT. CURRENTLY THE CHECK ENGINE LIGHT IS ON, THE PASSENGER SEAT AIR BAG IS DEACTIVATED AND IT IS UNSAFE TO SIT IN THE PASSENGER SEAT AS THE AIR BAG COULD MALFUNCTION AT ANY TIME, ALL DUE TO THIS FLOODING AND THE ROOT CAUSE BEING THE FAULTY DRAINAGE SYSTEM THAT RUNS FROM THE SUNROOF THROUGH THE DASH OUT OF THE BOTTOM OF THE CAR. THERE IS A CLASS ACTION LAW SUIT, NO. 2:10-CV-04407-DMC-MF, AGAINST VOLVO FOR THIS SPECIFIC ISSUE, I BELIEVE THIS ISSUE IS LEADING TO MORE AND MORE PROBLEMS OVER TIME, MY VEHICLE CURRENTLY WON'T START AND THERE ARE ONLY $75K MILES ON IT, I BELIEVE WATER DAMAGE IS THE ROOT CAUSE FOR ALL ISSUES WITH THE VEHICLE AT THIS TIME, THERE SHOULD BE A RECALL ON ALL VEHICLES EFFECTED OR COMPENSATION TO KEEP DRIVERS SAFE IN THIS SPECIFIC VEHICLE. *TR

THE SUNROOF LEAKS AND CAUSES PUDDLES IN FRONT DRIVER SIDE AND DRIVER SIDE PASSENGER SIDE, RUST AND MILL-DEW SMELL ALSO ELECTRICAL ISSUES IN THE VEHICLE WHY? EVEN AFTER SHORT TIME OF PURCHASING A CAR. VOLVO SHOULDN'T MAKE CUSTOMERS PAY FOR THIS EXPENSE COST SINCE MOST OF THESE ISSUES SEEM TO PLAGUE MANY VOLVO CUSTOMERS. *TR

I WAS ON HIGHWAY 410 HEADED TO I35 IN RUSH HOUR TRAFFIC AND THE POWER TO THE ENGINE SHUT OFF WHILE I WAS DRIVING.. I HAD TO GLIDE THE CAR TO SAFETY. *TR

AT LEAST 5 TIMES I HAVE HAD THE CAR IN THE VOLVO DEALERSHIP. THE CAR WITHOUT WARNING, POWERS DOWN TO 50%, THE WINDSHIELD WIPERS START UP, ALL THE GAUGES DROP TO ZERO POSITION AND ABS BRAKE MALFUNCTION LIGHTS LIGHT UP. IF YOU PULL OVER AND STOP, THE CAR SHUTS DOWN AND YOU CAN NOT PULL OUT THE KEY. IF I WAIT 15 MINUTES, THE KEY CAN BE TURNED OFF AND YOU CAN RESTART THE CAR. WHILE THE CHECK ENGINE LIGHT STAYS ON, EVERYTHING ELSE IS NORMAL TILL THE NEXT TIME. IT HAD DONE THIS 6 TIMES IN THE LAST 6 MONTHS. DEALER CAN NOT FIGURE IT OUT OTHER THEM A ELECTRICAL MALFUNCTION FROM SOMEWHERE IN THE COMPUTER. IF IT HAPPENS GOING UP A GRADE OR HILL, THE POWER DOWN SLOWS THE CAR IN WHICH IS IS SOMETIMES IMPOSSIBLE TO POWER UP OVER THE HILL. EVERY TIME WE TAKE IT TO THE DEALER, IT THEN RUNS WITH NO PROBLEM, BUT LASTS 2 OR 3 WEEKS BEFORE ACTING UP AGAIN. THEY HAVE CHANGED THE BATTER, ALTERNATOR, UNPLUGGED AND REPLUGGED THE COMPUTER TERMINAL. THIS CAR IS UNSAFE AND UNRELIABLE TO TAKE ON LONG TRIPS. DO YOU KNOW OF A RECALL TO GET THIS PROBLEM FIXED ? *JS

WHILE DRIVING AT NIGHT WITHOUT WARNING: ?INTERIOR LIGHTS, WIPERS ON ?ALL GAUGES WENT TO ZERO ?ALL WARNING LIGHTS, AIRBAG, STABILITY CTRL, ABS, OTHERS-ON ?NO TURN SIGNALS OR HAZARD LIGHTS ?NO DOOR LOCKS ?NO WINDOW OPERATION ?RANDOM MESSAGES SUCH AS TRUNK OPEN ?ALL PROBLEMS CONTINUING CANNOT DRIVE CAR DURING PREVIOUS INCIDENTS GAUGES STARTED JUMPING, LIGHTS BLINKING, WARNINGS FLASHING, CAR HAS COMPLETELY SHUT DOWN WHILE DRIVING. *TR

CAR WAS PARKED IN THE DRIVEWAY AT MY HOUSE OVERNIGHT. WHEN I OPENED THE DRIVER'S DOOR TODAY MID-DAY, I SAW GLASS ALL OVER THE FRONT SEATS. THE SUNROOF HAD EXPLODED UPWARD. THE EDGES OF THE GLASS STILL REMAINING IN THE SUNROOF ARE CLEARLY PUSHED UP AND OUTWARD, NOT DOWNWARD INTO THE CAR AS IT WOULD BE IF SOMETHING HAD FALLEN THROUGH THE SUNROOF FROM THE OUTSIDE. OTHER THAN SHATTERED GLASS, THERE WAS NOTHING UNUSUAL (SUCH AS A BRANCH OR ROCK) INSIDE THE CAR. NUMEROUS SIMILAR INCIDENTS ARE POSTED ON CARCOMPLAINTS.COM, INCLUDING ANOTHER VOLVO S40. *TR

TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL PUMP AND PUMP ELECTRONIC MODULE (PEM) NEEDED TO BE REPAIRED. THE DEALER ALSO INFORMED THE CONTACT THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM). THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 56,000. ...UPDATED 11-12-13 *BF THE CONSUMER STATED IN THE PAST MONTH THE ALTERNATOR, DEFECTIVE PCV, AND CVVT HUB. THE DEFECTIVE PCV CAUSED THE FRONT SEALS TO BLOW WHICH CAUSED THE CVVT HUB TO NEED TO BE REPLACED. UPDATED 11/25/2013 *JS

TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED WHENEVER THE AIR CONDITIONER WAS ACTIVATED, HOT AIR EMITTED THROUGHOUT THE VENTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE FAILURE WAS CONTRIBUTED TO THE AIR COMPRESSOR. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

DRIVING IN RAIN, BRAKE FAILURE MESSAGE BEGAN FLASHING ON DASH, THEN AIRBAG FAILURE. SLOWED TO A STOP AND TURNED OFF CAR, TURNED BACK ON AND DROVE SLOWLY HOME. MESSAGES CONTINUED TO FLASH. DROVE TO SERVICE CENTER AND MESSAGES WERE NO LONGER FLASHING , MECHANIC SAID IT WOULD NEED TO BE ACTIVE TO FIND PROBLEM. SAME SCENARIO MANY TIMES SINCE AND THE PROBLEM HAS BECOME WORSE, DRIVING DOWN HIGHWAY AND MESSAGES APPEAR THEN ALL GAUGES ON PANEL FAIL AND GO TO ZERO, WINDOWS FAIL, BLINKERS, BRAKE LIGHTS FAIL, ENTIRE INSTRUMENT PANEL WENT DARK. BACK TO MECHANIC, HE DROVE IT SAME THING HAPPENED THEN STOPPED BEFORE RETURNING TO SHOP SO COULD NOT DIAGNOSE.EXTREMELY DANGEROUS AS SEVERAL TIMES DRIVING IN RAIN AND IN HIGH TRAFFIC AREAS AND ON FREEWAYS WITH HIGH SPEEDS AND THEN IN CONSTRUCTION ZONES BUMPER TO BUMPER WITH NO BRAKE LIGHTS OR ABILITY TO USE TURN SIGNALS. HAS BEEN OUT FOR FIVE TO THIRTY MINUTES AT A TIME THEN APPEARING TO WORK AGAIN BEFORE REPEATING THE SAME FAILURE PROBLEM. NEVER ANY WARNING, IT JUST HAPPENS SUDDENLY. TO MECHANIC AGAIN, CODES READ AND PRINTED OUT PAGES OF SIGNAL FAILURES, NONE ACTIVE AT TIME SO UNABLE TO DETERMINE PROBLEM. CHECK ENGINE LIGHT HAS ALSO APPEARED AND WHEN CHECKED NOTHING ACTIVE FOUND AT TIME OTHER THAN PAGES OF SIGNAL FAILURES IN SYSTEM. *TR