1999 VOLVO V70 Complaints

ENGINE BEGAN TO RUN ROUGH FOLLOWED BY LOSS OF ACCELERATION THEN STALLING. CAR STALLED IN TRAFFIC CAUSING TRAFFIC JAM. SUBSEQUENTLY RESTARTED AND DRIVEN TO DEALER FOR REPAIR. PARTS REPLACED WERE THROTTLE CONTROL BODY, GASKET AND ETM RELOAD AT A COST OF $942. *NM

MY WIFE AND DAUGHTER WERE DRIVING IN OUR VOLVO V70XC (1999) ON A BUSY HIGHWAY WHEN IT STALLED SUDDENLY. SHE COASTED TO THE SHOULDER AND STOPPED THE VEHICLE. SHE WAS UNABLE TO RE-START THE VEHICLE. THE FUEL GAUGE INDICATED PLENTY OF FUEL SO RUNNING OUT OF GAS WAS RULED OUT. SHE CALLED FOR ASSISTANCE AND THE VEHICLE WAS TOWED TO A LOCAL GARAGE. THE TECHNICIAN DIAGNOSED THE PROBLEM AS A FAILED FUEL PUMP & INJECTOR. THE FUEL PUMP AND INJECTOR WERE REPLACED AND THE VEHICLE STARTED. THE COST WAS APPROXIMATELY $1800. WITHIN 3 DAYS IT HAPPENED AGAIN. THIS TIME WE TOOK THE VEHICLE TO A VOLVO DEALER. THE TECHNICIAN DIAGNOSED THE PROBLEM AS AN ELECTRONIC THROTTLE CONTROL MODULE. THE COST WAS APPROXIMATELY $1200. THE VEHICLE DOES NOT STALL ANY MORE, BUT AFTER $3000 IN REPAIRS, IT HAS AN ERRATIC IDLE WHICH IS AN ANNOYANCE. I READ AN ARTICLE AUG 01, 2005 (AP ONLINE VIA COMTEX) WHERE OTHERS WHERE HAVING THE SAME PROBLEM. MY CONCERN IS THE SAFETY OF MY FAMILY WHEN OUR VEHICLE STALLED SUDDENLY WITHOUT WARNING ON A BUSY HIGHWAY. NOT TO MENTION THE $3000 IN REPAIRS! *NM

I OWN A 1999 VOLVO V70 XC. THE CAR SUDDENLY STOPPED AND STALLED. I WAS ABLE TO RESTART IT AND DRIVE IT. I WAS TOLD THAT THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) HAS FAILED AND NEEDS REPLACEMENT. I AM TOLD THAT IF I DO NOT REPLACE THIS PART, $1000+ REPAIR, THAT THE CAR CAN EXPERIENCE A SUDDEN STALL AGAIN. DOING SOME RESEARCH ON THE INTERNET AND TALKING TO THE MECHANIC IT SOUNDS LIKE THIS IS A VERY COMMON PROBLEM WITH CERTAIN VOLVO'S. IT WOULD SEEM TO ME THAT BECAUSE OF THE FREQUENCY OF FAILURE AND SERIOUSNESS OF POTENTIAL SAFETY ISSUES VOLVO WOULD HAVE ADDRESSED THE ETM PROBLEM A LONG TIME AGO. THANK YOU. *NM

FAILED ELECTRONIC THROTTLE MECHANISM; FAILED FOR MY WIFE IN TRAFFIC. SHE WAS ABLE TO RESTART AND GET HOME. WHEN I TOOK THE CAR OUT TO CHECK ON THE SYMPTOMS IS COMPLETELY DIED(STALLED) WHILE I WAS STARTING TO MAKE A LEFT TURN(ACROSS ONCOMING TRAFFIC LANE) INTO MY DRIVEWAY. I WAS ABLE TO RESTART AND GET OUT OF THE ROAD WITHOUT ANY INCIDENT. THIS FAILURE CREATES A DANGEROUS SITUATION FOR THE DRIVER AND PASSENGERS. THANK YOU. *JB

PLEASE INCLUDE MY VEHICLE INCIDENT TO NHTSA ACTION # PE05041. WHILE DRIVING ON THE HIGHWAY THE VEHICLE ETS (ELECTRONIC THROTTLE SYSTEM) WARNING LIGHT CAME ON. VEHICLE WAS ABLE TO DRIVE HOME. NEXT DAY VEHICLE WOULD NOT START, HOWEVER, WAS ABLE TO START BY BYPASSING GEAR SELECTOR INTO NEUTRAL AND VEHICLE STARTED AND WAS TAKEN TO VOLVO DEALER. VOLVO REPLACED THE ETS UNIT AND RELOADED THE SOFTWARE UNDER THE SPECIAL CA EMISSIONS WARRANTY. SINCE VOLVO REPLACED THE PART WITH AN IDENTICAL UNIT, I AM CONCERNED THE UNIT WILL FAIL AGAIN OUT OF WARRANTY AND I WILL HAVE TO REPLACE AT MY COST ($1,000.00). VOLVO SHOULD REDESIGN AND REPLACE ETS UNITS TO VOLVO OWNERS AT NO COST. *JB

INCIDENCE 7 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: EVER SINCE THROTTLE WAS DONE A COUPLE OF MONTHS AGO, FEELS LIKE IT IS GOING IN AND OUT OF GEAR WHILE DRIVING- FEELS FOR A MICRO SECOND AT VARIOUS TIMES GOING IN AND OUT OF GEAR. NINO CAN CALL FOR MORE INFO IF NECESSARY. REFER TO RO 435245 09/17/04 78697 MILES - FOUND DEFECT IN THROTTLE UNIT ASSEMBLY REPLACED -- TECHNICIAN FOUND CODES FOR ETM INTERNAL MALFUNCTION. REPLACED ETM AND PERFORMED DOWNLOAD." THIS INCIDENT WAS THE 7TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I HAVE REPORTED ALL THE PREVIOUS INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. NOTE THAT THIS PARTICULAR INCIDENT SEEMS TO BE CONSISTENT WITH ALREADY-RECOGNIZED NHTSA ACTION NUMBER PE05041 "FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES." PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208 5) ODI #10131209 6) ODI #10131213. *JB

INCIDENCE 6 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: ETS LIGHT CAME ON AFTER DRIVING CAR AT HIGHWAY SPEEDS. WHEN DECELERATING DOWN TO LOCAL (TOWN) SPEED CAR HAS A SEVERE SPUTTERING, HESITATION AS IF IT WAS GOING TO STALL. FAULT TRACED SYSTEM WITH VADIS AND RETRIEVED CODES ECM-532D ECM-9190, ECM-91A7, AND ECM-91F0... REPLACED ELECTRONIC THROTTLE ASSEMBLY, AND DOWNLOADED NEW SOFTWARE TO ADAPT CAR." THIS INCIDENT WAS THE 6TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. NOTE THAT THIS PARTICULAR INCIDENT SEEMS TO BE CONSISTENT WITH ALREADY-RECOGNIZED NHTSA ACTION NUMBER PE05041 "FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES." PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208 5) ODI #1013120.*JB

INCIDENCE 5 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: CHECK ENGINE LIGHT ON. THERE ARE DRIVE ABILITY CONCERNS. CAR CUTS OUT INTERMITTENT RIGHT AFTER STARTING - WARM OR COLD START. SEE ATTACHED. ACCESS DIAGNOSTIC CODES: ECM 2110 AND ECM 720A. REPLACE IMMOBILIZER ANTENNA RING AND FRONT OXYGEN SENSOR. RESET ADAPTATION." THIS INCIDENT WAS THE 5TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208. *JB

INCIDENCE 4 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER REPORTS: 1) WHEN SLOWING DOWN TO A STOP TACH DROPS AND THEN PICKS BACK UP WHEN CAR COMES TO A STOP. CLEAN THROTTLE HOUSING. 2) WAS GETTING 20 MILES PER GALLON NOW ABOUT 17 1/2. PERFORM SOFTWARE UPGRADE FOR ECM, TCM AND ETM." THIS INCIDENT WAS THE 4TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207. *JB

INCIDENCE 3 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "[THROTTLE & CRUISE] CUSTOMER REPORTS: ETS LIGHT COMES ON INTERMITTENTLY - LIGHT GOES OUT ON RESTART. ACCESS DIAGNOSTIC CODES: ECM 91A7. PERFORM SOFTWARE DOWNLOAD & RESET ADAPTATIONS." THIS INCIDENT WAS THE 3RD OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206. *JB