2018 VOLVO XC60 Complaints

While driving, the engine will shut off while stopped and fail to restart when the gas pedal is engaged. The car will not turn on, the steering column and brake pedal lock rendering it completely unresponsive to any attempt to restart the vehicle. It has now happened over six times and Volvo has made two attempts to fix it, but it continuously occurs.

There is a know issue with suspension that Volvo is not addressing. XC 60 owners are reporting the car was shuttering and vibrating heavily under acceleration or coasting at different speed (at 30K miles). This is getting more severe with increased mileage. Volvo has redesign the CV joint, but has not advised owners. The issues: 1- The right drive axle had a play 2- Front Prob drive shaft CV Joint is defective: The dealer showed me the new redesigned version where it is marked with a green line. If you don't see the green line on your prob shaft, this means you might have the old design one and will probably be defective. Volvo has redesigned but not replacing the defective part. The vibrations becomes more severe with increased speed and adversely effects steering, maneuverability and control on the vehicle.

Tires are Continental Cross Contact 255/45R20 105H. Miles - 39,000. Severe vibration started coming from rear of car at speeds starting at 45 mph. Alignment was done which did not resolve the issue. Tires removed from rim and two found to be failing inside. The noise reducing foam glued to the inside wall of the tire tread had become almost entirely detached and bunched up in a unsymmetrical configuration. In addition the rubber on the inside where the foam had been was ablating off the surface. This causes a 10oz imbalance in each tire. Additional photos available if requested.

Have brought car twice for vibration and shutter when vehicle is driven on highway. The shutter is extreme and only stops when car comes to a dead stop at an intersection or toll. Increasing speed or lowering speed does not stop the extreme shutter felt in wheel and passenger compartment. Car has only 37,000 miles on odometer! This extreme vibration and shutter is intermittent and not all the time.This problem has been previously reported to NHTSA as propeller shaft front head on AWD system. Portland Volvo has done alignment on 10/10/22, but could not find reason for shutter/shimmy. Brought car back to dealer on 10/27/22 and they found nothing. Bringing car back to dealer on 11/16/22 for same problem.

Rainwater leaked into front of vehicle and settled in undercarriage causing a short in the passenger side airbag and error message for gear selector. The warning light for the airbag lit up. The vehicle has been inspected by a dealership and the cause of the problem was a clog in the drainage system under the windshied. The clog was redirecting water down into the vehicle and destroyed the main wiring harness. My passenger's safety was at risk because the airbag malfunctioned during driving. Other components could have also shorted out. The ability of the rainwater to drain into the vehicle's electrical components is the result of poor water drainage design and could be remedied easily.

Distracting Dash warnings “POWER STEERING ASSISTANCE TEMPORARILY REDUCED”, auto parking warning come on while driving and engine pause during stops working intermittently. Start/Stop doesn't work like its supposed to, only works intermittently, only works beginning of drive & then doesn't work rest of travel

June 4, 2022, 2018 Volvo XC60 - Right rear door lock engaged and would not release from either inside or outside door handle with all doors electronically unlocked. No other doors were affected. The door remained locked until Volvo technician removed inside door panel and made temporary repair on June 6. Replacement lock assembly was not available until Friday, June 10 when it was replaced by the dealer. Lock failure put safety of rear passengers at risk and I did not allow passengers in the back seat until lock was replaced. There was no warning lamp or message indicating lock failure. Dealer service representative said the failure mode was mechanical. Repair made under warranty.

When Pilot Assist's steering assistance is unable to keep the car in the lane, it will disengage without any audible warning nor visual warning (screen flash, popup message,...). The only indication is the 3/4" steering wheel icon at the bottom left of the instrument cluster, changes color from green to grey. It has been behaving this way since the day I purchased the car in early 2018 and continues to behave this way today. The owner's manual makes no mention of any audible or visual warning. The owner's manual can be downoaded at Volvo's website https://volvo.custhelp.com/app/manuals/ownersmanualinfo/year/2018/model/XC60

Distracting Dash warnings “POWER STEERING ASSISTANCE TEMPORARILY REDUCED”, auto parking warning come on while driving and engine pause during stops working intermittently. Wife refuses to drive vehicle due to warnings that involve steering issues.

Brakes continue to malfunction & I am having to replace brakes & rotors each time at approximately 25k mile intervals. Local dealership in Baton Rouge Louisiana & Lafayette Louisiana continue diminish my concerns and state this in normal wear for this vehicle. i am certain this not the case.