2019 VOLVO XC60 Complaints

The polyurethane foam inside the tire came unstuck, resulting in severe shaking in the car above 40 miles an hour. The tire came on a new 2019 Volvo XC 60 that’s a dealer would not replace the cost of the tire

The contact owns a 2019 Volvo XC60. The contact stated that the front headlights failed to properly illuminate when engaged. The vehicle was diagnosed by an independent mechanic and the contact was informed that the headlight assemblies needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the contact was informed that the vehicle was out of warranty. No further assistance was offered. The approximate failure mileage was 45,000.

For the last 18 months, when getting on or while driving on the interstate at speeds of 55 - 70 mph, the steering wheel vibrates and a vibration is felt throughout the vehicle. When braking a pulsation is felt in the brake pedal and the car shudders as it slows. I have taken it to the dealer and they cannot duplicate the issue. I've seen that other Volvo XC-60 have had similar issues with brakes/rotors.

Driving down the interstate in rush hour at 30 mph, the entire entertainment system as well as the dashboard went black and went through a system restart. The dashboard, including spedometer and related controls were black and unusable for approximately 10 seconds. Approximately 3 minutes later, the system reboot again and all visual aids were unusable for 10 seconds or so.

After I parked my car, the driver’s seat back tilted forward towards the steering wheel and could not be repositioned either manually or electronically. I could barely squeeze in and certainly could not drive the car with the seat in that position. The car needed to be towed to the dealer and Volvo replaced all related components, which were under warranty. If this had occurred while I was driving, the situation would have been extremely dangerous. There were no prior warnings of the seat back failure.

The contact owns a 2019 Volvo XC60 equipped with Pirelli tires, Tire line: Scorpion Zero, Tire size: 235/55/R19, DOT number: XB08V824219. The contact stated that while the vehicle was parked, the passenger side rear tire experienced a blowout. The contact's child was nearby when the tire exploded but did not sustain any injuries. The dealer was made aware of the failure and was sending a tow truck to tow the vehicle. The manufacturer was not made aware of the failure. The failure mileage was unknown.

WHILE I WAS DRIVING IN A BUSY MULTILANE CITY TRAFFIC SITUATION, THE CAR'S CENTER CONSOLE WENT COMPLETELY BLANK AND THE TURN SIGNALS, HAZARD LIGHTS, AND VOLVO ON CALL WERE NOT FUNCTIONING PROPERLY. I AM NOT SURE WHAT ELSE WAS AFFECTED. THIS CONTINUED FOR A FULL 1-2 MINUTES, UNLIKE TIMES BEFORE WHEN THE SYSTEM HAS DONE THE SAME THING BUT QUICKLY RE-BOOTED. THE SAFETY OF OTHERS AND MYSELF WAS COMPROMISED, AS I NEEDED TO CHANGE LANES TO GET ONTO THE INTERSTATE. I COULD NOT TELL IF MY SIGNALS WERE FUNCTIONING BECAUSE THE SIGNALS WERE NOT MAKING A CLICKING SOUND AND THE FLASHING SIGNAL INDICATOR LIGHTS WERE COMPLETELY NONFUNCTIONAL. I TRIED THE HAZARD LIGHTS AS WELL, WHICH DID NOT FUNCTION. I PRESSED THE VOLVO ON CALL BUTTON, BUT NOTHING HAPPENED. WHEN I TOOK THE CAR TO THE DEALERSHIP, THE SERVICE MANAGER STATED THAT A "SOFTWARE UPDATE" WAS PERFORMED TO FIX THE PROBLEM, AND WHEN I QUESTIONED HOW I WAS TO KNOW IF THIS WOULD BE A PROBLEM IN THE FUTURE, I WAS TOLD THAT I "WOULDN'T KNOW UNLESS THERE WAS A PROBLEM" AND THEY CLAIMED TO KNOW NOTHING ABOUT WHETHER THE INCIDENT WOULD BE REPORTED TO THE NHTSA. I FEEL UNSAFE DRIVING THIS CAR NOW, WHICH IS IRONIC CONSIDERING THAT I BOUGHT A VOLVO FOR ITS PURPORTED SAFETY.

SINCE PURCHASING IN MAY 2019, MY BRAKE PADS WERE REPLACED ONCE AND MY ROTORS NOW THREE TIMES. I HAVE LESS THAN 20,000MI ON MY VOLVO. THE REASON IS BECAUSE OF PULSATIONS WHEN I APPLY THE BRAKES AND IT CAN BE FELT IN THE STEERING WHEEL, AT TIMES. MY DEALER HAS BEEN STELLAR IN ADDRESSING MY CONCERNS EACH TIME I HAVE HAD TO HAVE IT SERVICED. I HAVE SEEN ON VARIOUS BLOGS AND CONSUMER SITES THAT THIS IS A RATHER COMMON OCCURRENCE. I BELIEVE THE ROTORS EITHER ARE NOT EQUIPPED FOR THIS VEHICLE OR THE QUALITY OF THE ROTORS ARE SUBPAR. IF A REMEDY OR RECALL IS NOT SUBSTANTIATED, THE OWNERS SHOULD BE ASSURED BRAKES AND ROTORS WILL BE COVERED BY VOLVO, INDEFINITELY.

WAS DRIVING ON HIGHWAY. I LET GO OF THE GAS PEDAL BUT THE CAR STILL UNCONTROLLABLY ACCELERATES! GAS PEDAL IS STUCK. HITTING THE BREAKS SLOWS THE CAR A BIT. THIS WENT ON FOR ABOUT 10 SECONDS AND FINALLY AND LUCKILY THE "R-DESIGN" GAS PEDAL COVER FELL OFF AND I WAS ABLE TO STOP ACCELERATING. INTENDED TO DRIVE AT 65 MPH BUT THE CAR ITSELF ACCELERATED TO UP TO 80 MPH MOMENTARILY.

TL* THE CONTACT OWNS A 2019 VOLVO XC60 HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH THE VEHICLE AHEAD SUDDENLY STOPPED AND THE AUTOMATIC EMERGENCY BRAKING SYSTEM DID NOT ACTIVATE CAUSING THE VEHICLE TO CRASH INTO A SECOND VEHICLE. NO INJURIES WERE REPORTED. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS TOWED AWAY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER FINDLAY VOLVO (5385 W SAHARA AVE, LAS VEGAS, NV) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 7,000.