2004 VOLVO XC90 Complaints

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHEN DRIVING VARIOUS SPEEDS, HE COULD HEAR A CLICKING NOISE COMING FROM UNDER THE DASHBOARD AND VARIOUS LIGHTS ON THE INSTRUMENT PANEL WOULD ILLUMINATE RAPIDLY. THE FAILURE RECURRED INTERMITTENTLY. THE CONTACT ALSO STATED THAT AFTER THE MOST RECENT FAILURE, HE WAS UNABLE TO START THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE. THE VIN WAS UNAVAILABLE.

WAS DRIVING AT HIGHWAY SPEED WHEN ALL ELECTRICAL SYSTEMS SHUT DOWN. DASH PANEL INDICATED BRAKE FAILURE, STOP CAREFULLY. NO LIGHTS, TURN SIGNALS, SPEEDOMETER, TACHOMETER, AIRBAGS, HAZARD LIGHTS, PWR WINDOWS, PWR BRAKES, RADIO - NO POWER TO ANYTHING. CLEAR, DRY WEATHER CONDITIONS. THIS HAD BEEN HAPPENING FOR SHORT CYCLES FOR APPROX. 2 MONTHS. WINDSHIELD WIPERS WOULD TURN ON FOR ONE CYCLE AND ALL POWER WOULD SHUT DOWN TO DASH, RADIO, LIGHTS ETC. BUT WOULD LAST FOR ONLY A SECOND OR TWO. THIS MIGHT HAPPEN 2-3 TIMES ON APPROX. 20 MILE DRIVE HOME ON HIGHWAY. THIS ONLY HAPPENS AT HIGHWAY SPEED. BUT THE INCIDENT ON THURSDAY 05.26.11 NO POWER LASTED FOR 10 MILES UNTIL I GOT THE VEHICLE HOME. HAD THE CAR SIT FOR AN HOUR AND THEN STARTED AGAIN AND THE DASH INDICATED SRS SYSTEM FAILURE BUT ALL POWER WAS RESTORED TO CAR.

THIS IS IN REGARDS TO MY VOLVO 2004 XC90. WHILE DRIVING MY VOLVO STARTS JERKING AND THEN ALL OF THE ELECTRICAL SYSTEMS GO OUT - ALL THE INTERIOR DASH LIGHT GO OFF, SIGNAL LIGHTS, AND HAZARDS WILL NOT WORK. I GET A MESSAGE ABOUT BRAKE FAILURE AND THEN SRS AIRBAG SERVICE. ONCE YOU STOP THE CAR AND RESTART IT FUNCTIONS NORMALLY WITH JUST THE SRS MESSAGE REMAINING. *TR

ENGINE WARNING LIGHT ALERTED A "BULB FAILURE". REPLACEMENT OF THE HEADLAMP CARTRIDGE DID NOT FIX THE PROBLEM. SINCE THE INCIDENT HAPPENED, I NOTICED SEVERAL OTHER XC90 SUV'S WITH SAME DAYLIGHT LAMP OUT ON THE DRIVER SIDE.

2004 VOLVO XC90 T6 "TRANSMISSION SERVICE URGENT" ERROR MESSAGE APPEARS. CAR JUMPS WHEN CHANGING GEAR AND SOMETIMES HAS NO POWER WHEN PUSHING THE GAS. CAR HAS 72K+ MILES. *TR

I OWN A 2004 VOLVO XC-90. I HAVE OWNED IT SINCE 12/2007. APPROXIMATELY 7 MONTHS AGO I STARTED HAVING INTERMITTENT ELECTRICAL PROBLEMS (NAVIGATION FAILURE, ENGINE SERVICE ALERTS, SECURITY ALARM SYSTEM FAILURE). MESSAGES WOULD APPEAR AND THEN STOP. RECENTLY WHILE DRIVING IN THE MOUNTAINS A MESSAGE APPEARED ABOUT A POSITION LIGHT FAILURE, THEN PROGRESSED TO MULTIPLE LIGHT FAILURES. THIS OCCURRED AT NIGHT ON THE BLUE RIDGE PARKWAY WHICH IS POORLY LIT IN MANY AREAS AND HAS WINDING ROADS WITH STEEP DROP OFFS. WE HAD TO DRIVE WITH MY PASSENGER AIMING A FLASHLIGHT TO SEE THE ROAD UNTIL WE COULD TURN OFF ON AN EXIT. THERE IS NO WHERE ON MOST OF THE PARKWAY TO PULL OFF AND WE WERE AT GREAT RISK WITHOUT HEADLIGHTS. WE CHECKED FUSES, AND THEN STARTED AGAIN AND HEADLIGHTS WORKED, SO DROVE ON. LATER ON THE INTERSTATE THEY FAILED AGAIN AND WE HAD TO PULL OFF AND PARK AND GET ANOTHER RIDE HOME. VOLVO CONFIRMED THAT THE CEM FAILURE IS A VERY COMMON OCCURRENCE WITH XC90S. THEY USED TO KEEP SOME OF THESE ON HAND DUE TO COMMON NEED TO REPLACE. AS WITH OTHER OWNERS, I NOW HAVE A $1200+ REPAIR TO REPLACE THIS. THIS SHOULD BE A RECALL ITEM - HIGH RATE OF OCCURRENCE AND SAFETY ISSUE. WHY WAIT UNTIL SOMEONE IS KILLED? IT IS ONLY A MATTER OF TIME TILL HAPPENS WITH CEM FAILURES.. *TR

I WAS DRIVING, AND JUST AS IT STARTED TO GET DARK, I NOTICED THAT MY LIGHTS DID NOT SEEM TO BE WORKING. I STOPPED AT A PARKING LOT TO CHECK, AND THE LIGHTS WERE IN FACT NOT WORKING. IF I HAD NOT BEEN CLOSE TO HOME, IT WOULD HAVE BEEN A PERILOUS DRIVE HOME; AND, IF IT HAPPENED HALF AN HOUR LATER, I WOULD HAVE BEEN ON A BUSY HIGHWAY WITH NO LIGHTS.

WHILE DRIVING ON THE HIGHWAY, MY WIPERS CAME ON FOR ONE CYCLE. A FEW MINUTES LATER THE SAME THING. THEN A FEW MINUTES AFTER THAT THE WIPERS CAME ON, STAYED ON, AND MY ENTIRE ELECTRIC PANEL SHUT DOWN. NO DASH BOARD INSTRUMENTS, NO POWER IN THE WINDOWS, NO TURN SIGNALS, NO STEREO. CAR STILL RAN, AND HEADLIGHTS STILL WORKED. PRETTY SCARY. WHEN I STOPPED THE CAR, TURNED OFF THE ENGINE, AND TURNED IT BACK ON AGAIN, EVERYTHING RETURNED TO NORMAL EXCEPT FOR A SRS MESSAGE. THIS SEEMS TO HAPPEN WHEN THE CAR IS STUCK IN TRAFFIC OR IS HOT. MY DAUGHTER WAS GOING 65 MPH ON A HIGHWAY AFTER BEING STUCK IN TRAFFIC FOR A WHILE. SHE PANICKED BECAUSE ALL LIGHTS AND DASH WENT OUT AND SHE THOUGHT THE ENGINE HAD STOPPED. SHE COULD HAVE HAD AN ACCIDENT!!!! LAST TIME IT HAPPENED WE GOT AN ERROR CODE FOR AIRBAG FAILURE. THIS IS NOT GOOD! *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING AT ANY SPEED, THE CONTACT NOTICED A LOUD THUMPING NOISE COMING FROM THE FRONT END OF THE VEHICLE FOLWED BY THE ILLUMINATION OF ALL WARNING LIGHTS INCLUDING THE CHECK ENGINE, ABS AND SRS WARNING LIGHTS. THE ENGINE CONTINUED TO RUN; HOWEVER, ALL THE ELECTRICAL POWER FAILED. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE CONTACT DID NOT INFORM THE MANUFACTURER SINCE HE WAS AWAITING A SERVICE APPOINTMENT WITH THE DEALER. THE CURRENT AND FAILURE MILEAGE WAS 62,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING APPROXIMATELY 40 MPH THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE RESTARTED AFTER PULLING ONTO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIANS WERE UNABLE TO DIAGNOSE THE FAILURE. THE TECHNICIANS PERFORMED UPDATES TO THE COMPUTER. THE VEHICLE WAS AT THE DEALERSHIP AND HAD NOT BEEN DRIVEN SINCE THE UPDATES WERE MADE. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS AND REFERRED THE CONTACT TO THE DEALER FOR FURTHER QUESTIONS AND CONCERNS. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.