2004 VOLVO XC90 Complaints

2004 VOLVO XC 90 , 2.5 AWD. WHILE DRIVING ON I40 AT NIGHT ,(65 MPH, IN DRIVE) A LOUD THUMP FOLLOWED BY MOMENTARY ELECTRICAL FAILURE( HEADLIGHTS, LOSS OF ENGINE POWER.) IT THEN PICKED BACK UP AND CONTINUED ON FOR APPROX 1/4 MILE AND IT HAPPENED AGAIN. MADE INTO FAR RIGHT LANE FROM THE 3RD LANE OVER. OTHER THAN THE RADIO VOLUME EVERYTHING WORKED AS NORMAL THE NEXT 40 MILES TO HOME. THIS HAPPENED AT APPROX. 9:30 PM IN THE MIDDLE OF THE INTERSTATE . WHAT IF THE LIGHTS HAD FAILED AND IT NOT REGAINED POWER, 40/85 IS A BUSY HIGHWAY AT NIGHT. I WAS DRIVING WITH MY WIFE AND 2 KIDS. *TR

I HAVE A 2004 VOLVO XC90 THAT NEEDS THE CEM REPLACED A COST OF $1400.00. AS I WAS DOING RESEARCH ON MY CARS PROBLEM I NOTICED THAT ALMOST EVERY MODEL OF VOLVO HAS THE SAME ISSUE. THE CEM IS THE COMPUTER THAT CONTROLS EVERYTHING. WHEN MINE WENT BAD I WAS DRIVING 70MPH DOWN THE INTERSTATE AND THE CAR JUST SHUT OFF. VERY DANGEROUS!!!!! *TR

TRANSMISSION FAILURE ON 2004 VOLVO XC90. THIS IS A KNOWN PROBLEM BY VOLVO BUT THEY HAVEN'T ISSUED A FORMAL RECALL. THE SERVICE DEPARTMENT I DEAL WITH STATED THEY REPLACE ON AVERAGE 10 A MONTH. THE AVERAGE COST THAT OWNERS ARE FACING IS $7000. *TR

"TRANSMISSION SERVICE URGENT"LIGHT IS ON. I PURCHASED THIS VEHICLE "NEW" IN JULY 2003. CURRENTLY HAS 87,000 MILES. NOTICED SLIPPAGE OVER ONE YEAR AGO. ACCELERATION AT TIMES AFTER BEING STOPPED VEHICLE WOULD HESITATE FROM SLIPPAGE, DANGEROUS AT INTERSECTIONS MAKING TURNS IN FRONT OF ONCOMING TRAFFIC. RESEARCHED ONLINE AND DISCOVERED THIS MODEL HAS NUMEROUS, NUMEROUS REPORTS AND COMPLAINTS REGARDING TRANSMISSION FAILURES WITH A WIDE RANGE OF MILEAGE. VEHICLE ROLLED BACK AFTER BEING STOPPED AT A INTERSECTION TODAY 10/04/10 AND I STRUGGLED TO GET VEHICLE TO ACCELERATE AND GET IT HOME. BARELY MADE IT INTO THE GARAGE WHEN I NOTICED THE TRANSMISSION SERVICE LIGHT WAS ON. *TR

2004 VOLVO XC 90 AND TRANSMISSION IS FAILED AS WELL AS MOTOR MOUNTS, WHEEL BEARING BOOTS, ETC. DEALER KNOWS ABOUT THESE RECURRING ISSUES WITH OTHERS OF SAME YEAR, BUT CLAIMS IT IS ONLY MY ISSUE. PURCHASE PRICE WAS ~$55K AND WITH ONLY 106K MILES I SHOULD NOT NOW HAVE TO SPEND ~$5K FOR A NEW TRANNY. *TR

TL*THE CONTACT OWNS A 2004 VOLVO XC90. WHILE TRAVELING 35-45 MPH THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE TIRE HAD SUDDENLY TURNED OUTWARD RUBBING AGAINST THE WHEEL WHICH CAUSED THE VEHICLE TO COME TO STOP. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 77000.

THERE IS A LOW BEAM FAILURE INTERMITTENTLY ON THE DRIVER'S SIDE REGARDLESS OF WHETHER I'M USING THE DAYTIME RUNNING LIGHTS OR THE BI-XENON HEADLIGHTS. THE BULB HAS BEEN REPLACED, FUSES CHECKED, WIRING CONNECTIONS CHECKED AND THE FAILURE CONTINUES. THE ONLY INCIDENT THIS HAS CAUSED HAS BEEN A WARNING FROM A POLICE OFFICER ABOUT GETTING IT REPAIRED. I HAVE TAKEN IT BACK TO THE DEALERSHIP TWICE AND THEY INDICATE THAT EVERYTHING IS RUNNING FINE, HOWEVER THE BULB FAILURE TYPICALLY HAPPENS AFTER THE CAR HAS WARMED UP AND HAS BEEN DRIVEN FOR A WHILE. *TR

WHILE DRIVING IN RAIN ABOUT TWO OURS LEFT HEADLIGHT WENT OUT TWICE BUT CAME BACK ON, ALMOST FLICKERING MOTION. NOTICED THAT THE ELECTRICAL SYSTEM INSIDE CAR FLICKERED AS WELL. HEAD LIGHT WENT OUT AGAIN FOR THIRD TIME AND SO I PULLED OVER AND TURN THE CAR OFF AND BACK ON AND WAS FINE. CONTINUED DRIVING FOR ANOTHER 30 MINS WHEN ALL OF A SUDDEN ENTIRE ELECTRICAL SYSTEM WENT OUT DURING DRIVING. TOTAL BLACKNESS. THE ONLY THING I COULD DO WAS STEER TO THE SIDE OF THE ROAD AND STOP. TURNED THE CAR OFF AGAIN AND BACK ON AND WORKED FINE BUT HAD "SRS" AIRBAG WARNING LIGHT. *TR

COMING HOME TO SOUTHERN CALIFORNIA FROM A TRIP IN ARIZONA AND DRIVING AT NIGHT THOUGH THE NEVADA DESERT. WEATHER WAS NICE, DRY CONDITIONS, LIGHT TRAFFIC ( THE SUN HAD SET ABOUT 7:00 IN THE EVENING) - JANUARY 2008 AND WE WERE CRUISING AT ABOUT 65 MPH. AT ABOUT 50 MILES OUTSIDE BANNING THE CAR HAD A POWER SURGE, AND IT FELT AS IF WE WENT OVER A BUMP ON THE ROAD, THERE WAS A QUICK FLICKER IN ALL LIGHTS AND THE NAVIGATION SYSTEM RESET. THE RECOVERY WAS ALMOST IMMEDIATE AND DID NOT THINK MUCH OF IT. ABOUT HALF HOUR LATER IT HAPPENED AGAIN. THIS TIME STARTED TO WORRY ABOUT THE CAR AS IT WAS DARK, HAD SMALL KIDS IN THE CAR AND WE WERE IN THE MIDDLE OF NOWHERE, DESERT FOR MILES AND MILES. SO, WITH NO OPTIONS WE KEPT DRIVING. ABOUT TEN MINUTES LATER IT HAPPENED AGAIN. THIS TIME THERE WAS NO RECOVERY. ALL LIGHTS, INSTRUMENT PANEL, HEADLIGHTS, EMERGENCY LIGHTS, REAR LIGHT ALL OUT. THE CAR WAS PITCH BLACK. I BELIEVE ONLY THE FOG LIGHTS WERE WORKING BUT WAS WORRIED ABOUT VISIBILITY ON THE ROAD AS WE HAD NO REAR LIGHTS WHAT SO EVER AND THE MAJORITY OF THE TRAFFIC AT NIGHT ON THE I-10 IS TRUCKS. DROVE ON SHOULDER FOR ABOUT 2 MILES AND TOOK THE NEXT EXIT. SMALL GAS STATION ONLY, NO REPAIR SHOP, NO MOTEL NOTHING; ONLY A TRUCK STOP. AFTER A SMALL RESPITE WE STATED UP THE CAR AGAIN AND ENGINE AND ALL LIGHTS WERE AGAIN FUNCTIONAL. I WAS TERRIFIED OF DRIVING THE CAR HOME STILL OVER 100 MILES AWAY AND NO WHERE NEAR CIVILIZATION, BUT SINCE WE HAD NO OTHER CHOICE WE DID. NO FURTHER INCIDENTS UPON GETTING HOME. DEALER HAD NO IDEA WHAT COULD HAVE CAUSED THAT, THEY UPDATE COMPUTER CODES, AND A CONTROL MODULE. TO THIS DATE THEY STILL DO NOT KNOW WHAT COULD HAVE CAUSED THAT. WE ARE VERY LUCKY TO HAVE NOT GOTTEN INTO AN ACCIDENT OR WORSE. *TR

2004 VOLVO XC90. CONSUMER STATES PROBLEM WITH TRANSMISSION *TGW THE CONSUMER STATED THE VEHICLE WAS JUMPING INTO GEAR OR LUNGING WHEN HE APPLIED THE ACCELERATOR PEDAL. THE CONSUMER STATED THE ORIGINAL TRANSMISSION WAS REPLACED AT 53,000 MILES IN 2008. THE DEALER PERFORMED A DIAGNOSTIC CHECK AND DETERMINED THAT THE FRONT AXLE HAD LOST A PLUG AND THAT THE TRANSMISSION HAD BECOME CONTAMINATED AND THAT WAS THE CAUSE OF THE JUMPING IN THE TRANSMISSION. THE REPAIR OF THE FRONT AXLE AND TRANSMISSION FLUSH WAS APPROVED AT VOLVO'S COST. HOWEVER, DIAGNOSTICS ALSO REVEALED THE PASSENGER SIDE AIR BAG WAS DEFECTIVE AND NEEDED TO BE REPLACED. *JB