VOLVO Complaints

I was driving down the road at 60mph, and my car started to wobble a little bit. I pulled over to see if something was obviously wrong and I didn't notice anything. At this point I thought that maybe I needed a new rear shock, but when I got back on the road, the wobble was so bad that I couldn't drive 25mph. I drove about 20mph until I could get to a safe place to pull over which was only about a mile. I took the wheel off and this was the moment that I noticed the tire had swelled up to the point that it wouldn't stand upright. It just fell over. I bought the tire (Riken Raptor) brand new 11 months ago. There is still a lot of tread on the tire. I had the presence of mind to pull over as soon as I noticed something wasn't right. I fear that if I had been on an interstate highway going 70mph, then something really bad may have happened.

1. When putting vehicle in reverse the backup camera has a slight delay which can cause serious accidents. I've never driven a vehicle with such delays. Needs to be checked out. 2. When putting vehicle in reverse, the backup camera comes up, ut if you press any button on the main screen the backup camera screen will go away. For example I press the AC button, the backup camera will disappear and the AC settings will come up. This causes a very dangerous situation. There isn't even a way to get back the camera view once you press anything on the screen. This happens because Volvo cars don't have much physical buttons left, so everything is controlled on the screen. In my opinion, when reversing, the backup camera should always be the dominant thing on the screen, no other functions should be able to overwrite that.

Water leakage from top of windsheild due to common failure of sealant (known to Volvo) falls directly into steering wheel airbag and, from there, flows into the seam between airbag module and the steering wheel and collecting behind the airbag subjecting the electrical connections of the airbag to moisture trapped behind the airbag. See photos. No warning lights yet. Vehicle is available for inspection by nhtsa.

In Tank Fuel Pump, problem was leaking at top of pump @ the inlet at the outlet & return valve, crack in the plastic mold. Was giving off fumes, totally unhealthy and waitin for someone to light up a cigarette for a total car explosion and death for all occupants. I have replaced the pump myself. Local Dealer wanted 1100 plus to replace out of my budget This in my view it should have been done by recall, local Jim Volvo of Portland, Oregon said no, out of warranty period. I disagree, If unrepaired, I would have been risking me and my family or occupants in the vehicle at the time. There are still many of these cars and other models & years that I found my research on the web that has had this same problem. I have a 1998 Volvo s70 that appears to be developing the same issue. I had come to like my 2003 S80, it will be my last Volvo My cost so far About $150, and 1st pump I installed was defective, had to start over [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The top of the windshield no longer adheres to the body of the vehicle. My searches of the internet have found multiple instances of the Volvos where the top part of the windshield is no longer attached to the vehicle. Here is a link to the Auto Glass Safety Council describes the issue (https://agsc.org/volvo-glass-bonding-issue/). Volvo Car USA LLC recently issued a statement that all windshield replacements on Volvo vehicles must be performed “according to Volvo standards at an authorized facility, using only Volvo Genuine Windshields and adhesives.” Their reasoning for this statement is, “The Volvo windshield is an integral part of our vehicles. Not only does it provide an undistorted view, it serves as a critical structure component on the vehicle." Since Volvo is claiming there is a safety component to the windshield and only Volvo can fix it, they should recall and repair all vehicles with this known issue.

The contact owns a 2015 Volvo S60. The contact stated while driving 20 MPH, the brake pedal was depressed however, the vehicle failed to stop until the brake pedal had gone to the floorboard. There was no warning light illuminated. The vehicle was taken to the dealer, but no failure was found. The contact stated that the failure had occurred several times. The contact stated that the vehicle was test driven by the mechanic however, the cause of the failure was not yet determined. The manufacturer was made aware of the failure and no assistance was offered. The failure mileage was approximately 14,000.

Several ounces of water leaking onto drivers hands on steering wheel from top of windshield when braking in adverse weather conditions is a severe and dangerous distraction to driving and braking. Condition first noticed in first heavy rain storm soon after using drive-through car wash, and persisted and worsened steadily thereafter. This condition is particularly dangerous as it occurs only when driver attempts to slow the vehicle at an intersection, and water in the roof flows forward into, and fills, the cavity that contains the top edge of the windshield with a large quantity of water which then flows onto the driver's hands and lap with no warning. Dealer is aware of defective windshield seals common to this year and model but will not assume repair beyond warranty period.

- Back left axle went loose with the back left wheel while driving, causing the car to rotate 45 degrees, scratching the ground. Once the car drifted back horizontally, I used the brakes to stop the car. Multiple pictures show the defect. Back left lights where the axle went off and the wheel is not broken, showing no collision. Liquid escaped from the bottom. Available for inspection and photos as well. -Had I not been able to use the brakes after the car rotated sideways, we would have crashed. This could have caused major injuries to us and/or others. -The police inspected the car and didn't qualify it as an accident since they said no damages, other objects, or vehicles were involved. The manufacturer's local shop made a 4 lines and inaccurate report to qualify it as an accident falsely. If there were an accident, lights would brake before the axle and there was no pothole -There were no warnings. It happened suddenly

The tensioner pulley for the serpentine belt seized up while traveling at 70 mph, melting the serpentine belt and causing an engine fire.

Vehicle shakes at highway speed (62-75mph) and under heavy acceleration (highway on ramp) since 1st day of owning vehicle. Steering wheel vibrate and rear mirror shakes and is unusable. Took to dealer on 3rd day of owning car and they balanced tires and performed alignment with no improvement. Dealer stated it is a problem known to Volvo with no corrective action and they were instructed by Volvo to not fix anything.