VOLVO Complaints

A FEW YEARS AGO I RECEIVED A EXTENDED WARRANTY FOR A FUEL PUMP RECALL. MY FUEL PUMP IS NOW LEAKING GAS AND FILLING THE CAR WITH GAS FUMES. WHEN I CALLED THE VOLVO DEALER I WAS TOLD THAT THE EXTENDED WARRANTY WAS NO LONGER VALID AND IT WOULD COST $1,000.00 TO HAVE IT FIXED. I CALLED THE VEHICLE SAFETY HOTLINE AND WAS TOLD THAT MY VIN NUMBER WASN'T INCLUDED IN THE RECALL AND I WOULD NEED TO FILE A COMPLAINT. THE CAR IS 16 YEARS OLD AND IS IN GOOD CONDITION I FEEL THAT AS VOLVO KNOWS THAT THE FUEL PUMP IS A SAFETY ISSUE THAT ALL CARS THAT HAVE THE SAME FUEL PUMP ISSUE THAT ARE STILL DRIVING THE HIGHWAYS SHOULD BE INCLUDED IN THE RECALL. NOTHING HAPPENED OTHER THAN THE HEAVY FUEL SMELL THAT FILLS THE CAR WHEN DRIVING AND THE FUEL CAN BE SMELLED OUTSIDE OF THE CAR AFTER IT HAS BEEN TURNED OFF. I HAVE HAD THE CAR FIXED BUT THINK THAT THE FUEL PUMP ISSUE SHOULD STILL BE ADDRESSED. I DIDN'T HAVE AN ACCIDENT AND THERE WAS NO FIRE, BUT THERE COULD HAVE BEEN.

FOLLOW UP TO 09/16/2019 COMPLAINT ID NUMBER 11255771. THE ENGINE NOISE WAS DIAGNOSED AS SIGNIFICANT INTAKE CAM SHAFT BEARING(S) WEAR. THIS WAS NOT A LUBRICATION ISSUE PER THE DEALER, SO APPARENTLY A MANUFACTURING ERROR. THIS CAUSED METAL CONTAMINATION THROUGHOUT THE ENGINE IN THE OIL. PER THE DEALER, 2 OTHER XC90'S HAD THIS SAME PROBLEM IN THE US. THROUGH THE VIP EXTENDED WARRANTY, A NEW LONG BLOCK ENGINE WAS AUTHORIZED AND INSTALLED, MINUS A $100 DEDUCTIBLE. A $15K-$20K SERVICE (PLUS ALL DIAGNOSIS') FOR THE $100 DEDUCTIBLE IS NOT A BAD DEAL. THE ENGINE SOUND IS NOW GONE AND IS IDENTICAL TO A NEW CAR. HOWEVER, THE CONFIDENCE IN VOLVO IS DECREASING. SAFETY, COMFORT, BEAUTY ARE ALL TOP NOTCH. BUT MECHANICAL ERRORS LIKE THIS ARE CRAZY FROM A $60,000+ VEHICLE.

TL* THE CONTACT OWNS A 2018 VOLVO XC60. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH AN AUTOPILOT AND LANE KEEP SYSTEM. THE SYSTEM REQUIRED THE DRIVER TO OCCASIONALLY TOUCH THE STEERING WHEEL OR IT WOULD PROVIDE TWO WARNINGS. UPON THE SECOND WARNING, THE SYSTEM WOULD SHUT OFF, CAUSING THE DRIVER TO VEER OFF THE ROAD OR INTO ONCOMING TRAFFIC. THE CONTACT TESTED THE SYSTEM AND CONFIRMED THAT THE VEHICLE WOULD SWERVE OFF THE ROAD. THE CONTACT WAS CONCERNED THAT IF THE DRIVER WERE UNABLE TO RESPOND FOR ANY REASON, A CRASH COULD OCCUR. THE MANUFACTURER STATED THAT WHEN THE SYSTEM SHUTS DOWN, THE DRIVER SHOULD BE ALERT TO RESUME CONTROL OF THE VEHICLE. THE MANUFACTURER PROVIDED NO ANSWER FOR THE SCENARIO REGARDING IF THE DRIVER WERE UNABLE TO RESPOND. THE DEALER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2004 VOLVO S40 EQUIPPED WITH COOPER ZEON RS3-A TIRES, SIZE: 205/55/16R (NA). THE CONTACT HEARD A LOUD HUMMING NOISE COMING FROM THE TIRES. THE INSIDE OF THE TREAD HAD A LINE AND THE CONTACT NOTICED DAMAGE OR AN OPENING. AN INDEPENDENT MECHANIC CONFIRMED THAT THE TIRES WERE SEPARATING AT THE TREAD LINE. AN UNKNOWN TIRE DEALER STATED THAT THE TIRES WERE NOT UNDER WARRANTY AFTER THE TIRES HAD BEEN OWNED FOR OVER THREE YEARS. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE FAILURE MILEAGE WAS 145,000. THE TIRE FAILURE MILEAGE AND VIN WERE UNKNOWN.

MY CAR HAS AN ODOR FOR DAYS AFTER IT RAINS WHEN THE WINDSHIELD STREAMS WATER ABOVE THE DRIVERS STEARING WHEEL AND ALSO ALLOWS WATER TO STREAM DOWN INTO THE DRIVER'S SIDE FLOOR BOARD- IT'S A FULL ON STREAM OF WATER THAT COMES OUT THE TOP CORNER DRIVER SIDE OF THE WINDSHIELD AND ROLLS DOWN OVER THE STEARING WHEEL AND DRIVERS HANDS AND DOWN THROUGH THE DRIVERS FLOORBOARD OVER THE ACCELERATOR AND THE DRIVERS FEET. I'VE BEEN IN THE CAR DURING THE RAIN AND WHILE AT THE CAR WASH TO WITNESS THIS STREAMING OF WATER. THERE IS A 1 TO 2 INCH PUDDLE OF WATER THAT FORMS IN THE FLOOR BOARD RIGHT UNDER THE ACCELERATOR IF LEFT TO STREAM FREELY. THE WATER DOES NOT GUSH OUT RIGHT AWAY BUT SOMETIMES WILL REMAIN DRY UNTIL MOVING -HAS HAPPENED AT LOW SPEEDS WHILE PULLING OUT OF MY DRIVEWAY BUT AS DELAYED UP TO10 MINUTES LATER AFTER I'VE GOTTEN ON THE HIGHWAY WHERE I'M AT A SPEED OF @ 70MPH) ITS A HUGE SAFETY HAZARD- I HAVE BEEN STARTLED (SAFETY DISTRACTION) BECAUSE OF UNEXPECTED COLD WATER FLOODING MY FOOT AND MY PANT LEG WHILE ON THE ACCELERATOR.I'VE SPOKE TO AUTO GLASS REPAIR COMPANIES, WHO REPORT SEVERAL THINGS COULD BE HAPPENING BUT EITHER WAY, COST ME A LOT OF MONEY WHILE LIABILITY IS ON ME IF THEY ACCIDENTALLY CRACK THE GOOD WINDSHIELD IF IT ISNT A SIMPLE SEAL PROBLEM. THE MAJORITY OF WINDSHIELD REPAIR COMPANY'S I'VE SPOKEN TO STATE THAT THEY HAVE SEEN THIS BEFORE IN THIS MODEL VEHICLE AND IT HAS (IN THIER EXPERIENCE) BEEN A CRACK IN THE SUNROOF DRAINAGE SYSTEM? HOWEVER, JUST TO TEST THIS PROBLEM ALONE IS A $400+ IN SHOP DIAGNOSTICS - I HAVE ALSO READ ON VOLVO FORUMS AND ON NHTSA, OTHER OWNERS HAVE REPORTED THE SAME ISSUE I'M HAVING. IF ANYTHING, I WANTED TO REPORT THE ISSUE TOO IN HOPE OF GAINING INFO ABOUT WHAT THE PROBLEM MAYBE SO I CAN HAVE IT FIXED IN THE MOST EFFICIENT AND LESS COSTLY METHOD OR MAY IT LEAD TO FURTHER INVESTIGATION TO DETERMINE RECALL PROCEDURES.

MALFUNCTIONING SEAT BELT LATCHES AND BUCKLES- THE SEAT BELT LATCHES DO NOT RELEASE THE BUCKLE VERY GOOD WHEN NEEDING TO EXIT THE VEHICLE (THEY STICK IN PLACE UNTIL THE LATCH IS HELD AT A SPECIFIC ANGLE WHILE PRESSING THE RELEASE BUTTON) I DONT BELIEVE THIS IS AN INTENDED SAFETY FEATURE. THIS ISSUE IS PRESENT IN ALL 5 SEAT POSITIONS LATCHES AND BUCKLES IN MY CAR. AFTER SPECIAL ATTENTION TO UNBUCKLE MYSELF, I OFTEN HAVE TO WALK AROUND TO THE BACK DOORS TO GET IN THE BACK SEAT SO I CAN UNLATCH MY SONS BUCKLE ALSO. HE IS 6YRS OLD AND HAS NOT EVER HAD ANY PROBLEM UNBUCKLING HIMSELF IN OUR LAST SUV NOR IN OUR OTHER CURRENT CAR. HE HAS LOTS OF ANXIETY OVER THIS, HE PANICKS AND THEN WILL CRY BECAUSE HE FEELS HE IS TRAPPED IN. ALSO, THE BUCKLES DO NOT ALWAYS LOCK INTO THE LATCH WHEN PUTTING THE SAFETY BELT ON WHEN ENTERING THE VEHICLE. OFTEN TIMES WHILE IN ROUTE, THE SYSTEM WARNING LIGHT COMES ON TO NOTIFY ME THAT A BUCKLE IS NOT ON IN A SEAT POSITION BECAUSE ALTHOUGH THE BUCKLE SOUNDED AND FELT LIKE IT WAS LATCHED, IT WAS NOT.BUPON CHECKING THE SEAT POSITION THE SYSTEM WARNS, THE BELT FLYS RIGHT UP AND OUT OF THE LATCH, INDICATING IT WAS NOT SECURE AFTERALL. THIS ISSUE ALSO PRESENT IN ALL 5 SEAT POSITIONS LATCH AND BUCKLES. THE ISSUES ARE INTERMITTENT BUT OCCURS MORE THAN LIKELY MORE OFTEN THAN WE THINK BECAUSE WE HAVE GOTTEN USED TO THE DEFECTIVE FUNCTIONING AND HAVE ADAPTED TO DURING NORMAL USE OF THE VEHICLE. I AM CONFIDENT THAT MY FAMILY'S RISK OF HARM DURING A TRUE EMERGENCY IS GREATER BECAUSE OF THESE BUCKLES AND LATCHES AND THEIR MALFUNCTIONING.

I HAVE A 2012 VOLVO XC60 WITH AN ADHESIVE FAILURE AT THE TOP OF THE WINDSHIELD THAT IS APPARENTLY CAUSED BY A MANUFACTURING DEFECT THAT VOLVO HAS YET TO TAKE RESPONSIBILITY FOR REPAIRING AT THEIR DEALERSHIPS. THIS IS A SAFETY HAZARD. ACCORDING TO VOLVO: "THE WINDSHIELD IS ONE OF THE MOST IMPORTANT PARTS OF THE CAR. NOT ONLY DOES IT ENSURE AN UNDISTORTED VIEW ' IT ALSO IS A CRITICAL STRUCTURAL COMPONENT OF THE VEHICLE. THAT MEANS THE INSTALLATION PROCESS FOR WINDSHIELD REPLACEMENT HAS TO BE EXACT AND PERFORMED USING ONLY VOLVO GENUINE GLASS IN ORDER TO RETAIN THE ORIGINAL PROPERTIES. THE WINDSHIELD IS IMPORTANT TO THE STRUCTURAL INTEGRITY OF THE VEHICLE AND ALSO INTERACTS WITH MANY VOLVO SAFETY SYSTEMS. THE ONLY WAY TO PRESERVE PERFORMANCE AND GUARANTEE SAFETY IS TO INSTALL VOLVO GENUINE WINDSHIELDS. USING VOLVO-SPECIFIED ADHESIVES WILL BOND THE WINDSHIELD TO THE SAME STRENGTH AS WHEN ASSEMBLED IN THE FACTORY. IT'S IMPORTANT THE BOND HAS THE RIGHT STRENGTH FOR THE FUNCTION OF THE PASSENGER AIRBAG WHICH IS DESIGNED TO USE THE WINDSHIELD AS A SUPPORT WHEN DEPLOYED." HTTPS://WWW.VOLVOTECHINFO.COM/SITECONTENT/CERTIFIEDCOLLISION/FACTSHEETVOLVOGENUINEWINDSHIELD011419-FINAL.PDF I HAVE BEEN REFERRED TO AN AUTO GLASS SHOP BY THE VOLVO DEALERSHIP FOR REPAIR AND WAS TOLD BY THAT SHOP THAT THERE IS NO AFTER MARKET PART SO THE PART FROM VOLVO IS OVER $700.00 AND THAT I WOULD NEED TO BE PREPARED TO PAY FOR THAT PART SHOULD THE GLASS SHATTER UPON REMOVAL. *TR

TL* THE CONTACT LEASED A 2019 VOLVO S60. UPON LEASING THE VEHICLE, THE LANE KEEP ASSIST FEATURE ONLY WORKED APPROXIMATELY 10% OF THE TIME. ALSO, THE FORWARD COLLISION AVOIDANCE FAILED TO OPERATE. WHILE DRIVING 15 MPH, THE VEHICLE STOPPED ABRUPTLY ON A WIDE OPEN ROAD WITH NO OBJECTS IN VIEW. THE CONTACT STATED THAT AN UNKNOWN WARNING INDICATOR FLASHED WHEN THE FAILURE OCCURRED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT TO TAKE THE VEHICLE TO THE LOCAL SERVICE CENTER. THE CONTACT TOOK THE VEHICLE TO VOLVO CARS OF QUEENS (207-22 NORTHERN BLVD, BAYSIDE, NY 11361, 718-428-2118) WHERE HE WAS INFORMED THAT THE FAILURES WERE NOT A WIDESPREAD ISSUE; HOWEVER, THEY WERE FAMILIAR WITH THE DEFECTS. THE CONTACT WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE DEALER PROVIDED A LOANER VEHICLE AND INFORMED THE CONTACT THAT A DIAGNOSTIC WOULD BE PERFORMED. THE CONTACT WAS INFORMED THAT AN INVESTIGATION WOULD BE LAUNCHED WITH THE MANUFACTURER TO INVESTIGATE THE DEFECTS. THE VEHICLE HAD NOT BEEN RETURNED TO THE CONTACT. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2005 VOLVO S80. WHILE DRIVING 70 MPH AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE BEGAN TO DECELERATE. THE CONTACT STATED THAT THE CHECK ENGINE, ABS, AND BRAKE FAILURE, STOP SAFELY WARNING INDICATORS ILLUMINATED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS TAKEN TO MULTIPLE INDEPENDENT MECHANICS FOR DIAGNOSTIC TESTING AND THE FUEL SYSTEM FAULTY CODE WAS FOUND. THE VEHICLE WAS TAKEN TO AUTOBAHN VOLVO FORT WORTH (LOCATED AT 2910 WHITE SETTLEMENT RD, FORT WORTH, TX 76107, (844) 702-9350), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 140,000.

EXCESSIVE PREMATURE WEARING OF BRAKE PADS AND ROTORS. FROM PERSONAL EXPERIENCE AND DISCUSSING WITH OTHER OWNERS, VOLVO IS AWARE THAT THE BRAKES ON THE XC90 PREMATURELY WEAR (AS IN AFTER 1K-20K NEW BRAKES NEEDED ON ALL TIRES). THE LOCAL DEALERS ALL STATE THIS IS A KNOWN PROBLEM AND THEN DEMAND $1,000 TO REPAIR THE BRAKES. VOLVO'S BRAKES AND/OR BRAKING SYSTEM IS DEFECTIVE AND DANGEROUS AS THE BRAKES PREMATURELY WEAR OUT COSTING CONSUMERS UNNECESSARY MONEY FOR ADDITIONAL REPAIRS WHEN VOLVO COULD RESOLVE THE ISSUE.