VOLVO Complaints

Windshield appears to be defective. The glass has cracked in over 6 places, including inside and outside laminations. Cracks have appeared that are not related to rock impacts. The car has only 14K miles on it and the windshield already needs to be replaced.

I bought this car on 8/30/24. This car has the ability to turn off the lane keeping aid, BUT it defaults to steering assistance which can't be turned off. I was not aware of this before purchasing. This feature is a big problem and should be removed or allow the driver to deactivate. If I am driving and move out of my lane to avoid a pedestrian or stopped vehicle, the car automatically detects the solid line on either side of the car and steers me back toward whatever obstacle I'm trying avoid. This is seriously unsafe to be steered toward a pedestrian. I should not have to fight my car for control. I went to the dealer 9/10/24, and they confirmed that the system is working as designed and the steering assistance is supposed to take over.

Started getting high coolant temperature warning, indicating to slow down and then after a short while to stop the vehicle. The vehicle now cannot be driven without the warning showing up after several minutes of driving after sitting. Of course comes on much sooner if it's been running before that. We had to pull over and wait several times during interstate travel. No codes are present using a code reader. It reads the temp at around 215 degrees when warning comes on to slow down. Continues to increase until warning to stop vehicle. I inspected the engine. A lot of symptoms were inline with a bad thermostat. Changed that with no luck. I again inspected the engine and found the broken tube. It was inline with where it's supposed to be attached, so it was missed the first time. I researched online and found recall 19V308 related to a previous version of the part. The newer version is installed (Volvo part 31238231), yet the same exact conditions are present that the replacement was supposed to avoid. Seems reasonable that if that's the case, it should also be covered by another safety recall. The pics also include coolant accumulation in that area as well as corroded plastic conduit for what looks like some type of wire for electrical component. I'm not sure what that part is, but I've sent a pic also of where it goes into the engine. Seems like the higher heat that the coolant can reach eventually melted/corroded the conduit. The wire inside is also not in good shape, but is intact still.

The brakes did not work when the automatic emergency braking turned on. When I pressed the brakes all the way down, the brakes didn’t respond because it was still in automatic mode. I was able to swerve into the next lane to not hit the vehicle in front of me. The automatic emergency braking also turned on when I was reversing from a parked location when there was a vehicle waiting to park behind me and my vehicle stoped and didn’t come off of brake/park mode. I had to turn my vehicle on and off again to get it to move again. I have taken my vehicle in twice for shaking. My back rotors were replaced 2 weeks ago but my vehicle still shakes. This car only has around 21,000 miles to have so many issues already with rotors and shaking.

August 23rd, 2024, the car started hesitating when gas was applied. The transmission light came on, then the parking brake light came on saying it was turned off, the check engine light came on, the volvo on call light came on, and the car wouldnt turn off. I moved the shift into different gears, and was able to turn the car off. I waited a while and started the car again. This time the on call, and check engine light stayed on. I called the dealership, was told it was probably a low battery. Had me come in Monday the 26th to have it checked. But Saturday the car wouldn't start right away, and all the warning lights came back on and wouldn't shift gears. Had to call AAA to have it towed. Got a call from the dealership Monday August 26th. Was told they were testing the battery to see if it fails so they could replace it under warranty. They ended up replacing the battery, and told me there was a lot of water in the trunk under the spare tire, where the battery for the on call is located. Said there was a gap in the sunroof weather stripping where tree debris probably clogged the drain pipes. They cleaned that out, and replaced the sunroof weather stripping which was under warrenty. But I was told the water and clogged pipe was not under warrenty, and had to pay for that? September 6th, 30k service and check the on call light that never went off. They found 1.5 inches of water under my front carpet and will be checking for electrical damage and corrosion. They told me this is not covered under the warranty and advised to call my insurance. My safety concern is future electrical issues/ failures while driving. At any time something could malfunction. Thats a huge safety concern and not feeling safe to drive the car. There is nothing about this huge problem in the warranty or maintenance to check the drains !!! September 9th I will call the claims department and notify the adjuster. Also call back the dealership. Prior to this I've had no problems with the car.

The system that starts the vehicle, called a igs failed yet again. This failed at 700 miles in downtown chicago on the street blocking traffic. Now several months later today going on a trip and the vehicle dies in the middle of the street blocking traffic. Was unable to restart the vehicle again. Attempted to contact Volvo Customer Service and was on hold over 25 minutes without talking to someone. Tried to find a way to put vehicle into neutral to safely move out of the way, but this vehicle has no way to manually overrride it. It posed a safety risk and could of easily caused an accident.

The contact owns a 2019 Volvo XC60. The contact stated while the vehicle was parked, the front passenger's seat belt retractor did not function as intended. The vehicle was taken to the dealer where it was diagnosed with a failed front passenger's seat belt retractor. The contact was informed that the front passenger's seat belt needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was unknown.

There is a engine coolant leak from the plastic coolant line connector going into the motor

The reverse lights are not bright enough when backing up at night. When using the backup camera, the driver is unable to see anything behind the car, as the lights do not shine bright enough to illuminate the area of the camera. There is no way to adjust the brightness of the camera or the lights.

Vehicle steer violently on pilot assist and powertrain disabled, not allowing us to steer the wheel on a highway. (Last year) We were lucky no other cars were nearby, needed a reboot for the wheels to work again. Dealership isn’t sure what happened. Now we have a hybrid system failure which a lot of cars with the same model Xc90 T8 is having with the hybrid system. Please investigate into this