VOLVO Complaints

2016 volvo xc60 t5 has “srs airbag service urgent”. The message came without having any kind of an accident. The dealer says it’s due to electrical wiring or front seat movement.

Engine has excessive oil consumption and sets owners up for expensive testing and repairs, because when the original recall came out, many Volvo s60 with excessive oil consumption were barely out of the allowed mileage range, which sticks the owners with excessive repairs. Volvo should stand behind this problem that effects numerous Volvo s60’s and compensate the repairs.

Air conditioning is not working within one month of purchase. In 110 degree heat in Arizona , this is a safety issue. This has also occured on another new volvo xc90 in Austin , Texas. At least two failures on brand new volvo xc90.

Car is just back from the dealer for 40k service 2 days ago, while driving about 35mph a turtle icon and a check engine light came on car rate limited itself to 25mph had I been on a faster road I would’ve likely been rear ended

There is spontaneous cracking of the windshield without hit by a stone chip or any debri

My car experienced a cracked front left control arm. It was not in an accident and the crack caused a creaking sound when conducting turns.

Volvo mechanics claim the engine seized due to alternator pulley failure, however, at the time of the event, the engine showed no oil on the dipstick despite having added multiple quarts of oil over the last three months. Volvo has issued an extended warranty letter to customers due to excessive oil consumption, but Volvo failed to provide this letter for this vehicle. I’ve checked Volvo databases for engines matching this extended warranty and confirmed the engine is in fact covered under this extended warranty. Due to Volvo’s failure to communicate this problem, my daughter continued to drive this vehicle until it completely lost power in high speed traffic on I-95 nearly causing an accident and stranding her on the side of the interstate for several hours. Upon arriving at the cite of this incident, I notice there was no low oil warning light illuminated on the dash, so I double checked oil dipstick and added at least two quarts of oil. Unfortunately the engine had already seized at this point and the vehicle was inoperable.

The contact owns a 2016 Volvo S60 Cross Country. The contact stated that on several occasions while driving at various speeds, the check engine warning light illuminated, and there was smoke coming from the rear of the vehicle. Additionally, the contact stated that on several occasions while driving at various speeds, the vehicle started shaking and failed to accelerate as intended. The vehicle was towed to a dealer approximately five times, and an oil consumption test was performed. The contact also stated that the check engine warning light illuminated every five thousand miles. The manufacturer was notified of the failure. The failure mileage was approximately 79,000.

The contact owns a 2016 Volvo XC60. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was contacted but the vehicle was not diagnosed or repaired. The manufacturer was made not aware of the failure. The failure mileage was approximately 84,690.

This Volvo XC60 B8 has a serious deficiency with the 12v system and main Battery where it discharges below 10v when the vehicle sits idol for more than a week. Every 7-10 day interval the vehicle must be jump-started and driven for 30 min to recharge the 12v system. The vehicle reports itself in limp-mode until the 12v system charges above 11v then switches to normal drive mode for the remainder of the 30 min drive. I installed a battery tender to the POS and NEG posts under the hood but it charges the mild hybrid battery to full then disables continued charging of the 12v system, leaving the 12v main battery under voltage and draining while the car sits idol. We have to drive the vehicle for 30 minutes every 4-5 days to keep the battery charged. Not even Audi or Lamborghini require this much attention to their 12v systems like this 2022 Volvo. This dis-charging issue happens in all types of weather, all year long, and under any parked condition (locked or unlocked) and the factory battery charger only works on the hybrid battery, not the 12v system battery. I have owned other hybrid vehicles that can sit idol for weeks or months at a stretch and will start without issue. While parked, my Camry XLE (Toyota Synergy system mechanically disconnects their traction battery and simultaneously engages the 12v system to keep the Vehicle "aware" via sensors) will sit for months until I return to drive it normally. Volvo dealerships accept this behavior as normal although my experience with hybrid vehicles implies the opposite. I have not been able to uncover any online research that describes my issue with any resolution from Volvo or successful 3rd party auxiliary internal or external charging systems. it has been researched by Volvo to be 'within normal operating parameters'.