2009 BMW R 1200 GS Complaints

While attempting to pass a car on the highway, the engine suddenly lost power, forcing me into a perilous maneuver to reach the breakdown lane at highway speed. Following vehicle recovery and upon further inspection, I discovered that both plastic throttle body cam pulleys had broken in half, completely disabling throttle control. There were no warning lights or symptoms indicating this failure was imminent. In my research to fix the issue, I found that this problem is more common than I realized and poses a serious safety risk.

Throttle cable pulleys made of plastic have cracks. Catastrophic failure will eventually occur with zero warning, causing total loss of power. [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2009 BMW R 1200 GS. The contact received notification of NHTSA Campaign Number: 20V471000 (Fuel System, Gasoline) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact stated that after a short ride, the contact had made a stop and ran into a machine shop. The contact had parked (P) the vehicle and left it on. When the contact returned after a few minutes he saw that the vehicle had caught fire, the engine was still running. The location of the fire was from the gasoline tank and fuel pump assembly. The contact extinguished the fire using a large extinguisher available in the shop. The fire department was not called. The contact towed the vehicle to his motorcycle shop. The vehicle had not been repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 36,000. Parts distribution disconnect.

The Fuel line connector at fuel pump started leaking and spraying fuel onto the hot engine and exhaust pipes causing the Motorcycle to catch on fire! the 2nd fuel pump the recall was not done yet. The best I can tell the owner did not get the 2nd recall or didn't forward it to the next owner. The person who was riding the motorcycle at the time escaped from being burned! He put it out the fire with a fire extinguisher, bike looks totaled, confirmed by the Dealer. I brought the motorcycle to the BMW dealership in Kansas City it has been inspected. but not by the manufacture yet. no police report was made. No warning lamps or messages or symptoms just burst into flames!

Hello I would like to open a case on a fire recall :VIN wb10313089zu47089 2009 BMW 1200gs Motorcycle , The motorcycle did start on fire casing much burn damage at the fuel line , needed the update fuel line and pump update. Rider was able to escape the flames and get a fire extinguisher and put out the fire ! I called BMW of north America , at first they said take it to the Dealer for a inspection it should be fixed at no charge. Made appointment for the 7-20-23 at BMW of Kansas City , Then they called me back said it was not covered because the last owner failed to take it in for the 2nd fire recall new updated fix so they are not responsible , I will keep you updated after the 20th of July , Thanks Randall McGowen , 40211 E Boswell Rd , Lone Jack, MO ( 816-699-1089) p.s. I am a retired GM master tech , seen many fire safety recalls , it defiantly sprayed fuel from the defective part to start the fire , luckily no one was burned!

THERE HAD BEEN MANY MOTORCYCLE COMPLAINT ON SUSPENSION LEAKING PROBLEMS, WITH VERY LOW MILES ON. AND BMW IS NOT RESPONDING FOR THIS FAILURE. *TR

THE GAS TANK HAS QUICK DISCONNECT FITTINGS THAT SCREW INTO A PLASTIC FLANGE ON EACH SIDE OF THE TANK. THE FITTING THREADS ARE SIMILAR TO NPT PIPE THREADS WHICH OVER STRESS THE PLASTIC AND RESULT IN CRACKING, FUEL THEN LEAKS FROM THE TANK UNDER THE FAIRING ASSEMBLY ON TO ELECTRICAL WIRING, ENGINE PARTS AND HOT EXHAUST COMPONENTS. THIS COULD RESULT IN FIRE OR UNEXPECTED STOPPAGE CAUSING AN ACCIDENT OR FATALITY FROM A WRECK IN TRAFFIC. *TR

2009 BMW R1200GS. CONSUMER WRITES IN REGARDS TO FINAL DRIVE FAILURE IN MOTORCYCLE. *SMD THE CONSUMER SUBMITTED A PHOTO OF THE REAR WHEEL, TO SHOW THE EXTENT OF HOW THE GEAR OIL LEAKED. THE CONSUMER REFERENCED NHTSA CAMPAIGN # DP12001.

TL* THE CONTACT OWNS A 2009 BMW R 1200 GS MOTORCYCLE. THE CONTACT STATED THAT THE TRIANGLE WARNING LIGHT ILLUMINATED. THE VEHICLE ONLY HAD ONE WARNING LIGHT AND THE CONTACT WAS CONCERNED THAT IF ANY OTHER SYSTEM ON THE MOTORCYCLE FAILED, HE WOULD NOT BE AWARE OF THE PARTICULAR FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE FUEL LEVEL SENSOR FAILED. THE VEHICLE WAS REPAIRED BY REPLACING THE SENSOR. THE FAILURE RECURRED AND WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, HOWEVER NO ASSISTANCE WAS PROVIDED. THE CURRENT MILEAGE WAS 1,856. THE FAILURE MILEAGE WAS 1,500.

FUEL GAUGE NOT WORKING. HAVE HAD SEVERAL FUEL LEVEL STRIPS REPLACED. BMW DEALER TELLS ME THERE IS NO FIX. *TR