2006 CHEVROLET EXPRESS Complaints

SEAT BELT WOULD NOT UNLATCH AND WHEN I FINALLY GOT IT APART IT WILL NOT RELATCH NOW. *TR

MY FRONT PASSENGER AIRBAG SEAT SENSOR IS NOT FUNCTIONING. IT WILL NOT TURN ON AT ALL WHEN PEOPLE OF ALL DIFFERENT SIZES ARE IN THE SEAT. IF AN ACCIDENT WERE TO HAPPEN THE AIRBAG WOULD NOT DEPLOY. *TR

WE PURCHASED AN EXPRESS VAN IN THE SPRING OF 2006. TRUCK ENGINE BLEW UP AT 6000 WHILE DRIVING ON THE FREEWAY. IN JANUARY 2014, WE TOOK THE CAR INTO A DEALERSHIP BECAUSE IT STALLED 3 TIMES. THE DEALERSHIP PUT IT ON THE COMPUTER DIAGNOSTIC DEVICE AND COULD NOT FIND ANYTHING WRONG WITH THE VAN. APPROXIMATELY 3 WEEKS LATER, ON FRIDAY THE 24TH THE CHECK ENGINE LIGHT CAME ON, WE THEN TOOK IT BACK TO THE DEALERSHIP AND AT THIS POINT THEY TOLD US THAT THE TRANSMISSION WAS THE PROBLEM. THE CAR HAD JUST OVER 32,000 MILES WHEN TRANSMISSION BLEW UP IN JANUARY OF 2014. AFTER THE TRANSMISSION WAS REPLACED THE CAR CONTINUED TO STALL AND WAS TAKEN BACK INTO THE DEALERSHIP AND IT HAD A BUSHING BROKEN IN THE FRONT SUSPENSION. THIS VAN CONTINUES TO STALL AND AT TIMES FAILS TO START. WE ARE CONFIDENT THAT THE STALLING PROBLEM THAT WE ARE EXPERIENCING IS THE SAME AS THE CARS THAT ARE PART OF THE RECALL AND EXPRESS VANS SHOULD BE ADDED TO THE LIST OF RECALLED VEHICLES. THIS VEHICLE ONLY HAS 33,000 MILES ON IT AS OF MARCH 2014. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE BEGAN SHAKING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THERE WAS PREMATURE WEAR OF THE STEERING DUE TO THE PITMAN ARM ROLLING AGAINST THE OUTER AND INNER TIE ROD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,000. *TR

PAINT (WHITE) IS FALLING OFF VAN AT HOOD, SIDES AND MOSTLY ON AREAS WHERE THESES WELDED AREAS...DEALER SAID THEY NEVER SEEN THIS ISSUE?? I HAVE SEEN HUNDREDS OF THE SAME ISSUE ON OTHER VANS. *TR

WHILE DRIVING ON HIGHWAY TIRE SIDEWALL FAILED AND CAUSED BLOW-OUT OF TIRE. NEW TIRES WERE PURCHASED ON 6/12/2012. NEXEN TIRES 2457516A. THIS IS 2ND TIRE FAILURE FOR OUR VEHICLES. TIRE FAILED AT @ 17,000 MILES. WE HAVE PHOTO'S OF THIS TIRE. WE ARE VERY CONCERNED OVER THIS. 2 TIRES TOTAL FAILED WITHIN MONTHS OF PURCHASE. *TR

THE PROBLEM STARTED ABOUT A MONTH BEFORE THE INCIDENT. THE ABS LIGHT WOULD COME ON INTERMITTENT. AFTER A WEEK IT STAYED ON. WHEN THE LIGHT WAS ON THE BRAKES ACTED NORMAL EXCEPT NO ABS FUNCTION. I WAS DRIVING TO WORK (ABOUT 30 MPH) AND STEPPED ON THE BRAKE TO SLOW FOR A CURVE. WHEN I STEPPED ON THE BRAKE THIS TIME, I NOTICED THE ABS LIGHT WENT OUT AND THE VAN JERKED VIOLENTLY TO THE RIGHT. ON TO THE MUDDY SHOULDER AND INTO THE GUARD RAIL. *TR

WE HAVE A FLEET OF CHEVY G2500 EXPRESS VANS IN THE PAST 3 MONTH WE HAVE HAD TO REPLACE TWO LEFT FRONT HUB ASSEMBLY UNITS ON TWO DIFFERENT VANS IS THIS A USUAL PROBLEM? *TR

SUMMER TIME NOTICED ALUMINUM CORNER PANELS STARTED TO BUCKLE OR FLARE OUT FROM THE BOTTOMS THOUGHT IT POSSIBLY GOT HIT BYE A TRAILER BUT AS TIME WENT ON THEY FLARED OUT EVEN MORE THEN IN 2011 THEY STARTED PEELING OFF ON ONE SIDE ON EACH CORNER SO WE CONTACTED OUR DEALERSHIP WITH THE PROBLEM IN WITCH THEY TOLD US IT WAS RECALLED FOR THAT REASON THEIR WAS NO RIVETS IN THE CORNER PANELS SO THEY WOULD FALL OFF. SO WE CONTACTED SPARTAN SUPREME CORP WHO MADE THE BOX AND WAS TO WARRANTY THE BOX WHO CLAIMED OUR WARRANTY WAS UP. SO WE WENT DOWN BOUGHT PARTS SENT PICTURES AND WAS GOING TO FIX IT OUR SELVES. BUT AT LOOKING AT FIXING IT HAD GOTTEN SO BAD THAT THE CORNERS WAS NO LONGER STRAIGHT THE ENTIRE BOX IS SHIFTED AND IS BOWING OUT ON THE SIDES WITH JARRED SIDE PANEL SORS WHICH ARE RUBBING WHEN U SHUT THEM AND LOOKS UNREPAIRABLE. WE THEN CALLED AGAIN TO SPARTAN AND THEY TOLD ME IT WOULD HAVE BEEN UNDER WARRANTY WHEN WE CALLED THE FIRST TIME (EARLY 2011) AND NOW IT'S OUT OF WARRANT (LATE 2011). SO AT THIS POINT WE HAVE A BOX TRUCK WITH ON MISSING CORNER PANEL WHICH BLEW OFF SOMEWHERE OFF DOWN THE ROAD AND A LEANING BOX WITH WHICH COULD FALL APART AT ANYTIME. *TR

ON APRIL 29, 2011, A PASSENGER AND I WERE INVOLVED IN A VERY SERIOUS NEAR-FATAL MOTOR VEHICLE ACCIDENT. I WAS THE DRIVER OF THE VEHICLE, WHICH WAS A 2006 CHEVY EXPRESS CARGO VAN. WE WERE DRIVING FROM MEDFORD, OREGON TO KLAMATH FALLS, OREGON ON HWY 140 EAST. THE ACCIDENT OCCURRED NEAR MILE MARKER 59 AT APPROXIMATELY 8 A.M. THIS STRETCH OF HIGHWAY RUNS PARALLEL TO KLAMATH LAKE. THE VEHICLE SPUN OUT OF CONTROL WHEN WE DROVE OVER A PATCH OF UNSEEN BLACK ICE. AS THE VEHICLE SPUN OUT OF CONTROL WE WENT ACROSS THE HIGHWAY AND INTO THE LAKE WHERE WE COLLIDED HEAD ON INTO A HUGE BOLDER (NOT A ROCK) THAT WAS PROTRUDING FROM THE WATER. THE IMPACT CAUSED THE VEHICLE TO ROLL OVER LENGTH WISE AND THEN CAME TO REST UPRIGHT IN THE WATER. THE VAN SANK INTO THE WATER AND STOPPED SINKING WHEN THE WATER LEVEL HAD RISEN TO OUR CHINS. HIGHWAY PATROL AND AN AMBULANCE TEAM WERE DISPATCHED TO THE SCENE AND IT WAS NOTED THAT THE DUAL AIRBAG SYSTEM DID NOT DEPLOY. AS A RESULT I SUSTAINED SERIOUS INJURIES INCLUDING A FRACTURED STERNUM AND A VERY SERIOUS SHOULDER INJURY WHICH REQUIRED RECONSTRUCTIVE SURGERY AND A LENGTHY RECOVERY PERIOD. MY PASSENGER SUSTAINED MINOR INJURIES. I BELIEVE, AS WELL AS OTHERS, THAT HAD THE AIRBAGS DEPLOYED, AS THEY SHOULD HAVE, THE INJURIES I RECEIVED WOULD NOT HAVE OCCURRED OR WOULD HAVE BEEN GREATLY MINIMIZED. *KB