CHEVROLET Complaints

GM published bulletin PIP5681A on 10/05/20 regarding defective welds on the exhaust brackets near the catalytic converter. I had the same exact weld failure and GM is not honoring the warranty coverage, even though their bulletin said that all 2020 Traverse SUVs were included.

The contact owns a 2003 Chevrolet Corvette. The contact stated that while reversing from the driveway, the vehicle lost motive power. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 04V060000 (Steering). The vehicle was towed to the dealer, who replaced the relay and wiring harness kit. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 5,111.

Rattling noise started coming from the steering wheel, it can be felt through the steering wheel. Doing an inspection it's coming from the the U joint area and steering wheel. The steering wheel also doesn't properly turn back into place when turning at lower speeds. Issue started around 40k miles. Searching the online the issue lots of people are having the same issue. Per Chevy Dealership, In need of roughly $2,850 repair parts are Steering Gear, Steering Shaft, Steering ujoin

EVERYTIME IT RAINS REALLY HARD, MY DRIVERS SIDE B PILLAR WHERE THE HANDLE AND SEAT BELT IS, IS SOAK AND WET FROM A LEAK. THIS HAPPENS ALL THE TIME. I HAVE HAD MY SUNROOF CHECKED, MY WINDSHIELD CHECKED AND DRAIN TUBES CHECKED. THERE IS NEVER ANY WATER OR WETNESS ON THE FLOOR, ITS ONLY THE HEADLINER. THIS HAS BEEN AN ON-GOING ISSUE. I HAVE BEEN INVESTIGATING IF THERE ARE OTHER TAHOES DOING THE SAME AND YES THERE ARE AND 1 HAD WENT TO A BODY SHOP AND THEY FOUND OUT THAT THE MANUFACTURER WELDS WERE NOT WELDED CORRECTLY, WHICH CAUSES WATER TO GET INTO THE ROOF. THIS CAN CAUSE MOLD AND EVENTUALLY OTHER ISSUES. IT HAS STAINED MY HEADLINER. SOMETHING NEEDS TO BE DONE ABOUT THIS BECAUSE I CANNOT AFFORD TO HAVE A BODY SHOP FIX THIS KIND OF REPAIR AND I SHOULD NOT HAVE TO FOR AS MUCH MONEY AS I HAVE PAID FOR THIS VEHICLE. I HAVE VERY YOUNG GRANDKIDS THAT RIDE IN THIS VEHICLE AND ONE HAS VERY BAD ALLERGIES AGAINST MOLD. AND IT IS NOT FAIR THAT I EVENTUALLY WILL HAVE TO GET THIS FIXED BECAUSE IT WILL ALSO CAUSE RUST. PLEASE DO SOMETHING ABOUT THIS.

There is a well known exhaust issue with the catalytic converter and the separating manifold and no recall has been issue yet. It causes the vehicle to lose pressure and shuts off in the middle of traffic. The seat belt secure locks are malfunctioning and could cause loss of life in the event of an accident.

The contact owns a 2021 Chevrolet Malibu. The contact stated that while starting the vehicle, all the lights on the instrument panel illuminated, and the engine started to choke. The Service Vehicle light remained illuminated after the other lights turned off. The engine started choking again and failed to start. The vehicle was towed to a certified mechanic and was diagnosed with an inoperable fuel pump power control module. The mechanic informed the contact about a recall associated with the failure and referred the contact to the dealer for assistance. The vehicle was not repaired. The contact stated that the failure reoccurred the next two days. The dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was informed of the issue and confirmed that the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 72,000.

On June 27th 2026 at approximately 3am, I was driving my Chevy Silverado Trail Boss with 6.2 engine, it suffered a sudden catastrophic failure and it completely seized while in motion. There were no warning or signs given while vehicle was in motion. This resulted in an immediate highly dangerous loss of propulsion on a dark 2 lane road. The vehicle would not crank and had to be towed to Estero Bay Chevrolet.

Vehicle transmission repaired at 77,000 along with a new torque converter. Torque converter and transmission both failed again at 115,000 miles. GMC currently replacing the 3rd torque converter with 130,000 miles. I have spent over $14,000 on 2 transmissions and 3 torque converters on a vehicle I've owned for 6 years.

I have been having issues with my vehicle for the last 1,000 miles or so where it appears to be losing power while accelerating normally, i'm not sure if the issue lies with the engine or powertrain/transmission. I took to dealer last week and they were unable to reproduce. The issues have been getting more frequent and intially were only occuring after the vehicle warmed up, now it has started while vehicle is cold. Feels like the power drops (rpms drop) during a normal acceleration. As of 7/16 I now have a check engine light on, onstar indicates an issue with my engine, transmission, electrical. This is putting myself at safety risk along with others as during my normal drive the engine is losing power and could either leave me stranded or cause an accident.

My Chevy Silverado has a transmission defect that is under recall shift to park and my vin number is not included. I am disappointed because it’s exactly the same problem as the other ones.