CHEVROLET Complaints

I am reporting a dangerous failure of the fuel supply control module in my vehicle, which caused the engine to stall and cut off during acceleration while driving in heavy, 45-60 mph traffic. While I was able to have the issue diagnosed and repaired by Newman’s Auto—with an invoice available—I believe this 44,000-mile vehicle experienced a premature failure. Given that this component is currently recalled on similar Chevrolet SUVs and trucks, I believe this model should be included in the recall. I can be reached at [XXX] or [XXX] for further information. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Chevrolet Suburban. The contact stated that while changing the oil and filter, there were metal shavings found in the oil filter. The vehicle was not taken to the dealer; however, the dealer was notified of the failure over the phone. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 115,000.

Odometer Fraud. The contact purchased a 2010 Chevrolet Suburban. The contact stated that while driving approximately 55 MPH, the vehicle suddenly stalled. The vehicle was restarted and driven; however, approximately one minute later, the failure reoccurred. The vehicle was restarted and driven to a nearby parking lot. A certified mechanic arrived and inspected the vehicle. The mechanic diagnosed the vehicle with rod bearing failure, which caused damage to the engine. The vehicle was driven to the residence, and the contact was advised not to drive the vehicle to prevent a blown engine. The vehicle was not repaired. After the failure, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale on July 30, 2025. At the time of purchase, the mileage was approximately 180,000. The odometer indicated that the current mileage was 193,000. After researching the information on Infotracer.com, the contact discovered that on July 1st, 2001, the mileage was documented as 242,765. The manufacturer was not informed of the failure.

The contact owns a 2022 Chevrolet Traverse. The contact stated that while driving 65 MPH on the highway, the low oil warning light illuminated. A dealer was contacted. The vehicle was towed to the dealer to be diagnosed, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was consuming an excessive amount of oil. The manufacturer was not notified of the failure and opened a case, and stated that fifty percent of the cost of repair would be covered. The approximate failure mileage was 84,000.

Shift to park indicator comes on after shifting parking gear to park. Car fails to detect that it is in park even when it is.

The contact owns a 2006 Chevrolet Malibu. The contact stated that while pulling out of a parking space, the vehicle lost power steering functionality, causing the steering wheel to become difficult to turn. The power steering warning light was illuminated. The vehicle was pushed back into the parking space. The contact stated that the failure was intermittent. The contact stated that the steering gear was previously replaced due to a similar failure. The contact associated the failure with NHTSA Campaign Number: 15V064000 (Steering); however, the VIN was not included. The manufacturer was contacted and informed the contact that the VIN was not associated with the recall. The vehicle was not repaired. The failure mileage was approximately 158,000.

The Def guage does not work properly. After topping off with DEF the guage would not register being full. Also the guage would read over half full and within minutes I would receive a notification that the truck was going into limp mode due to be out of DEF. Happened several time while on a trip. Also truck went into limp mode while DEF was full.

The onstar module is broken and on significant backorder. Without it, standard features in my car such as GPS, onstar safety, remote control, and other features do not work.

On 3/21/2026 @ approximately 1:45 PM I was driving down a local road @ approximately 25MPH. While approaching a stop sign, I attempted to stop the vehicle, I applied the brakes and the brake pedal dropped serval inches and became hard felt like it hit the floor of the vehicle. The vehicle continued through the intersection. **There was NO warning message before the vehicle brakes failed to function as designed** There were children attempting to cross the street at the intersection, I blew my horn to alert the children, thank God that they Stopped and did not hit by the car. After the vehicle was brought to a stop there was a message Brake system failure.

My L87 6.2L engine shut off on the interstate while driving in traffic at 70mph. I coasted to the left shoulder and attempted to restart it, but it would not turn over. I had it towed to a dealer where they diagnosed it as seized. Currently waiting for a new engine to arrive with no ETA. I had no warning signs or sounds. Two months prior it had the recall completed passing the PICO test and changed to the heavier oil.