CHEVROLET Complaints

Unusual engine noise inspection at 86011 miles determined engine failure do to metal shavings and particles found in engine oils and oil filter by GM Dealership wher serviced only by them at mileage intervals on record and purchased new in 2019.

Total blackout. Lost all electronics, engine shut off and power steering gone while driving

The car is not sensing that it is in park when it is. When I place it in park and turn the car off it dings and says shift into park however it already is in park. Therefore the car will not turn off. I had to jiggle the shift or turn the car on, reverse then go forward then park to get it to register. This has taken up to 10 minutes and it’s getting worse. This is a known issue that is referenced in GM Technical Service Bulletin 19-NA-206.

6.2L engine failure. Camshaft and lifters. My [XXX] wife ([XXX]) was driving and it shut off going down the highway. It is at my local Chevrolet dealer getting repaired. No warnings. No engine light. Vehicle has 88,000 miles on it, I purchased it April 22, 2026 with 84,700 miles on it. My Chevrolet App says there are no issues with the vehicle..it’s in pieces at the dealership. I had higher standards for a high country. Always owned Chevrolets. May be my last one. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

COMPONENT: Electric power steering (EPS) steering gear / rack and pinion assembly. WHAT HAPPENED: The steering gear binds internally. After a turn the wheel does not return to center and must be forced back to straight; steering feel is stiff and clunky. On at least one occasion the wheel felt stuck in place partway through a turn and I had to fight it to finish the maneuver. I nearly lost control of the vehicle. Exact date, location and speed of that incident: UNKNOWN. The condition is chronic and has worsened over time. I own two Bolt EVs (2017's); both have this defect and I am filing a separate complaint for each. Mileage on this vehicle: approx 96,000 but it's been bad since 80,000 (at the very least). SAFETY RISK: Binding steering requires manual correction after every turn, increasing risk of overcorrection, unintended lane departure and delayed emergency response. Worst at intersections, on/off ramps and parking lots. The driver cannot anticipate when the wheel will stick. WARNING LAMPS / PRIOR SYMPTOMS: [No warning lamps, messages or codes appeared] Earliest symptom: [stiff or notchy steering]. First noticed [right away when I bought the car used]. CONFIRMED BY DEALER OR SHOP: [not yet presented] INSPECTED BY MANUFACTURER, POLICE OR INSURANCE: No. AVAILABLE FOR INSPECTION: Yes — vehicle and original steering gear assembly. This failure is widely reported across Bolt EV and EUV model years. GM service information contains a diagnostic procedure for poor return of the steering wheel, indicating the manufacturer is aware of it. No safety recall has been issued, and dealer repair runs $2,500-$3,500 because the subframe must be lowered to reach the rack. Videos of the repair are available online, which also include plenty of discussion about the symptoms and dangers: [XXX] and [XXX] I request that NHTSA open an investigation into the Bolt EV/EUV steering gear as this should 100% be a priority safety recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine failure of the 6.2L L87. Was 12 hours from home with my family on vacation in Colorado cruising up a 4 lane mountain highway about 700 yards from entering [XXX] thru the mountain and the engine started screaming and knocking. Thank the lord there was a way I could quickly steer my vehicle and family off the 65 mph hwy. Engine had recently passed the recall inspection test. “3,000ish miles ago” dealership confirmed engine failure and it’s sitting in cooorado waiting for a replacement engine. I believe this will be the 3rd engine now in my car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

6.2L LT1 GEN V AFM 138880 miles. Driving at highway speed no warning engine CATASTROPHIC FAILURE. Simotanious reaction first check engine light,no oil pressure,limp mode, piston connectioning rod thru side of block in 2seconds.Took to home town dealer. They reported to GM suposeabley. Dealer found lifter,valve spring,valve missing on right bank pulled oil pan found missing parts in little pieces.oil pan had 3 distinct holes in it. Ther had been no issues previous to this event.serviced regularly 5000miles by local dealer.

Component Affected: Visibility: Interior Trim / Entertainment Center Bezel Glare Description of Safety Hazard:The interior styling of the 2025 Chevrolet Silverado RST contains a design flaw involving the polished chrome trim strip located directly below the main central entertainment center/infotainment screen. Because of the angle of this specific trim piece relative to the driver's seating position, direct sunlight hits this lower screen border and reflects a concentrated, blinding glare directly into the driver’s eyes.This causes immediate, severe visual impairment and a temporary loss of forward visibility while driving. This distraction and blindness prevent the driver from safely observing the road and traffic, creating an imminent crash hazard. The manufacturer has failed to provide a non-reflective, matte finish for this specific entertainment center trim to prevent this hazard.

Engine failure from bearings and lower rod from lifters. This is the second engine failure in vehicle for the same exact reason per dealership report. Entire engine replacement both times and all lights on dash were on.

After having the original '25 6.2L GM L87 engine experience crankshaft bearing failure at approx. 5,700 mi, (previously reported to the NHTSA), the (brand new) replacement engine failed approx. 14,000 mi. later for the exact same reason, crankshaft bearing failure. In both incidents, the failure came 100% without warning, and the transmission LOCKED itself into park, leaving the vehicle and myself dangerously stranded in the middle of the highway; it had to be dragged on and off of the flat-bed tow truck both times.