CHEVROLET Complaints

When driving in traffic about 10 mph engine shuts down and power steering goes out. . When I slow to turn, the engine shuts down sometimes and the power steering goes out. No warnings. I’m afraid to drive it. I almost hit a lady while turning in a parking lot because the steering went out and it died. Sometime it’s hard to turn the key to start the truck. This has happened 9 or 10 times now.

In May 2025, the EGR (Exhaust Gas Recirculation) valve failed on my 2016 Chevy Volt with approx. 60,000 kms / 40,000 miles on it - that cost me approximately $3,000 to fix. In my opinion that should have been covered under warranty given that it is a common failure point on second generation Volts. Note that the EGR value (OEM - Original Equipment Manufacturer) is a readily available part. In October 2025, my BECM (Battery Energy Control Module) failed. Luckily, due to significant Volt owner complaints, GM was forced to provide a special warranty on this item, so the work that would have cost me approximately $4,000 was covered under this special warranty. The BECM is covered for my 2016 Chevy Volt until 2030. Note again that the BECM is a readily available OEM part. In December 2025 my Chevy Volt check engine light went on again, and this time the Chevy Dealership is telling me that the main hybrid battery needs to be replaced. However, GM decided in their infinite wisdom to discontinue production of the Chevy Volt battery, and so they can't even sell me a new hybrid battery, a critical component on this vehicle. My understanding is that the 2016-2019 Chevy Volt battery is the same part #24060122. The Chevy dealership has asked me to see if I can find a battery on my own, as their parts department cannot source one (GM used "York Electronics" in Canada). As a result, I am now left with trying to find a used/refurbished hybrid battery. If my Volt was a 2019 (the last year GM made the Volt), then this battery would be covered under warranty (8 years from in service date), yet GM wouldn't even be able to fix a 2018 or a 2019 Chevy Volt because they stopped making the battery for ALL Volts. How can a manufacturer get away with not even providing parts for 10 years (in my case), or 7 years (2019 Volt)? My only option seems to be to send a perfectly maintained car to the junkyard at 60,000 kms/40,000 miles. Never again will I buy GM.

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while shifting into park(P), the vehicle indicated that it was not in park(P). The contact turned off and restarted the vehicle, and then the vehicle began to work as intended. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and the contact was informed that the automatic shift control and gear shifter needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 24,000.

My car has a problem This will be the 3rd visit to the Chevy dealership and the 6th time in a garage. At this time, the original alternator that came with the Tahoe, was running high through December and replaced with a new alternator from Parts Geek. It was ok for a couple weeks and is running high again. You cannot test it from a cold start to get this reading. It must be ran for at least 20 min. After a certain amount of time the battery gauge will move to the highest point, the warning lights of ABs, traction control, stabilitrak, trailer brake light, battery light (first time on 1/27/2026 for battery light), loss of drivers assist on 1/26/2026, tire pressure light, car dies coming to a stop sign. I can’t turn it back on for at least a min. I’m stuck inside with zero power, can’t unlock the doors to get out to direct traffic, open windows or put on 4 ways so I don’t get smacked in the middle of the road. After that minute I heard a click (no key in ignition, not trying to start) and then the dash lights started coming back on again and I started it. The battery did not restart the time on the radio screen so I’m assuming I didn’t die fully. The radio screen always goes black first, then the heat goes in and out, the warning lights come on and it dies. Takes a minute or so to be able to start it again and the lights aren’t on anymore but will continue to do the same shit after awhile of driving and now daily. I’m afraid to drive it anywhere since almost getting stuck inside and plowed at an interaction. I have reached out to Chevy about this problem and was referred to take it back to the dealership again, and to reach back out as soon as it’s there to open a case on the issue.Ive had it, this has been ongoing for a year, and I have to keep paying for things that doesn’t fix the issue and it’s getting worse.

2017 chevrolet Equinox LT with a 2.4L ecotec engine. The PCV system froze due to the cold weather conditions caused the rear main seal to blow futher causing cylinder scoring to the engine. I got it checked out by a local mechanic that actually works with the extended warranty company called Silverrock that's provided from the dealership Drivetime from who I financed the truck from. The mechanic shop name is hoekstra muffler and alignment located at 722 W 151st St, East Chicago, IN 46312. They were the ones to diagnose the problem and provided me with a diagnostic sheet for this issue. The vehicle has not been checked by a chevrolet technician yet. I took the truck in for a regular maintenance oil change on January 8th at Walmart in portage, indiana. My truck was driving fine and suddenly on January 20th my truck seized on the highway on my way to work at 7am. A warning light marking low oil pressure turn off engine was marking on my dashboard. After i was in a safe spot on the side of the expressway, I have Life360 and proceeded to call for a tow truck. When the tow truck driver arrived in order to put the car in neutral he has to jump start my equinox. My truck will only start if it's jumped and keep the cables connected, otherwise it shuts off.

The contact owns a 2017 Chevrolet Colorado. The contact stated that while driving on several occasions at various speeds, the A/C unit stopped working, with the check engine warning light illuminated. On several occasions, while the vehicle was turned off, the cooling fan ran for approximately 2-3 minutes. The vehicle was taken to an independent mechanic where it was diagnosed, and determined that the engine coolant thermostat had failed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at various speeds, the front driver’s side seat belt buckle failed to remain latched securely and independently unlatched. The “SRS” warning light illuminated. In addition, the contact stated that on occasion, the driver’s side seat belt buckle failed to unlatch, and excessive force was needed to depress the unlatch button on the seat belt assembly. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. Upon further investigation, the contact associated the failure with NHTSA Campaign: 20V811000 (Seat Belts); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 11,000.

My truck passed the recall PICO test right at 20,000 miles. The dealer put thicker 0w40 oil in. Less than 2,000 miles later, upon hard acceleration from 5-8mph, the engine climbed to 58mph then lost power, shifted itself into Neutral and coasted to the side of road. Truck was towed and told the engine seized up. Changing the oil did not make sense to me as lubrication was always available previously, thickening it does not change the port mill sizes for properly oiling the crank bearings. Now the new engine is revised but I see failures in low milage 2026 models happening.

I purchased a 2012 Corvette from Coast Chevrolet on 1-24-26. This car was supposed to have been inspected for safety issues prior to being listed for sale. Being that this is a reputable General Motors dealership I assumed all safety issues and recalls would have been up to date. I drove the car home about 90 miles and immediately put it in my garage. After about 30 minutes of it being in there I noticed an overwhelming smell of gasoline. I began looking around the car both in the engine bay, underneath etc. I finally found the issue and cause for the smell. It was a leaking gas tank caused by the fuel pump. I did my research on it and found that this was a known widespread, common issue and that a service bulletin was put in place because of it. This is something the dealership should have made sure it was fixed prior to selling the car. I want this issue repaired by the dealership free of charge.

Component/System Failure The Supplemental Restraint System (SRS) failed to function as designed. Specifically, the driver steering wheel airbag and front passenger airbag did not deploy during a collision involving frontal impact forces. The vehicle is currently retained by the insurance carrier and is available for inspection upon request. Safety Risk The failure of the SRS materially increased the risk of serious bodily injury or fatality to the vehicle occupants. The driver experienced neck pain, persistent headaches, shoulder pain, back pain, weakness, cognitive fog, and a seatbelt-related neck abrasion, consistent with unmitigated crash forces. A minor passenger was present in the vehicle and was also exposed to increased injury risk due to the lack of airbag deployment. Confirmation or Reproduction of the Problem UNKNOWN. The airbag failure has not yet been evaluated by a dealer or independent service center to determine root cause. Inspections Conducted The vehicle will be inspected by insurance representatives in connection with the collision claim. A police report was completed at the time of the accident. The manufacturer has not yet inspected the vehicle or SRS components. Warnings or Prior Symptoms No airbag warning lights, SRS indicators, messages, or fault alerts were present prior to the collision. The vehicle previously underwent a manufacturer safety recall repair related to airbags, completed by an authorized repair facility more than one year before the accident. No post-repair warnings or abnormalities were observed prior to the collision. Additional Safety Concern Despite recall compliance, both front airbags failed to deploy, raising concerns of defective components, improper recall repair, or system malfunction. This failure warrants further investigation to determine whether similar vehicles may present an ongoing safety risk.