CHEVROLET Complaints

Due to cold temperatures, the main rear seal blew causing engine, coolant and intake systems to fail. Full replacements are now needed.

Vehicle currently at dealership for ESC, brake system and ABS warning lights coming on. Unable to use cruise control once these lights came on.

The contact owns a 2022 Chevrolet Malibu. The contact stated that while driving at 45 MPH, the message “Engine Power Reduced” was displayed, and the vehicle decelerated unexpectedly. The driver pulled over and was informed to turn off the vehicle and restart the vehicle with the assistance of a Police Officer. The vehicle was restarted but failed to exceed 10 MPH while driving. The vehicle was towed to the local dealer, where it was diagnosed with turbocharger failure. The vehicle was not repaired. The manufacturer was contacted and confirmed there was no coverage for the repair and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 62,000.

On 1/24/26 I used the remote starter to warm up the truck and it started but within 3 minutes it shut off. The temperature was in the single digits. So I tried the remote again and it wouldn’t start. And the remote start hasn’t worked since and the check engine light is on. Two years ago when the brake module failed right before that recall the temperature was very cold that day too. Just two months ago the check engine light came on and that time the dealership said the battery failed . It also printed out a whole page of errors , at the dealership.

While driving on the highway during morning rush hour the automatic braking fully engaged during slow traffic almost causing me to be rear-ended. The braking engaged after a split second collision warning after a car had merged in front of me. I was already slowing down via one pedal driving and about to begin applying my brakes when this occurred and there was plenty of space before any type of collision. I was going roughly 5-10 mpg when this occurred having slowed down to allow the car to merge. Afterwards it took a few seconds for the car to allow me to re-engage the gas to start moving again. This type of phantom braking has occurred in other instances in my driveway and in store parking lots but this is the first time it's put me at risk. It is available for inspection as needed. This has not been examined or reproduced by the dealer on my vehicle or inspected.

At 4400 miles on new truck started a random cylinder misfire which engine jerking and causes ESC, Emerg breaking and adaptive cruise control to turn off. Will reset itself then do it again. Little over 100 hours on new engine. It happens on longer trips on of off the highway.

I was pulling out onto the road and heard a noise in the front and right after my upper ball joint snapped completely off folding the tire underneath the truck and smashing the whole front end. Very lucky I was not on the highway. Had truck towed into my shop where after examination part failed prematurely. My insurance paid for it all which was just short of $10,000 in damage minus my $500 deductible and the tow bill. Now I have lost my safe driving deduction because of this claim, which caused my insurance to skyrocket. There were no prior warning signs, and I have my vehicle serviced and inspected regularly at my service provider.

the first engine blew while pulling out of my street onto a 45 mph road in march of 2025. they did the useless recall on the new engine and said it was good. The replacement engine blew in the november of 2025 in the fast lane at 80 mph. no warning no check engine lights just shut off. The replacement engine started make noise like it was going to blow again in december 2025. I paid 65k to have 3 bad engines in one year. corporate gm was of no help

the transmission lost power and almost caused an accident with the vehicle behind me

When using heated seats and heated steering wheel the headlights randomly pulsate and dim - dangerously impacting driver night-time vision / visibility and confusing / disorienting other drivers. Ongoing issue. Happens EVERY time headlights are utilized in conjunction with heated seats and heated steering wheel. Occurs at idle and at speed. Chevrolet refuses to acknowledge, address, or remedy the issue. Has not been remedied to date. Videos available.