CHEVROLET Complaints

Driving south on I95 under normal condition. After driving for about a hour truck started smoking under the hood. I pulled over and turned off vehicle. I released the latch to open hood. When I got out of the vehicle to lift the hood there were flames coming from both sides of the hood. I did not lift the hood. I moved away from the vehicle and called 911. Police and fire department responded and extinguished the fire. Vehicle was a total loss. GM indicates they will not investigate the cause and I should work through my insurance company for compensation.

Received a report from local auto repair and they found that the oil main seal is leaking. Issue happened in the highway and car automatically turned off the engine. I was not in an accident as there was no one else on the road and I was able to push it to the side. When the car turned on the wheel was stiff and hardly moved to the right or left. The warning received before the shut off was the service stabilitrack issues and when checked all oil completely depleted from the vehicle.

Thermostat issues, gives warning steering assist decreased and then eventually check engine light, vehicle thermostat does not react/reach normal temperature, fan continues to blow after car is turned off for 5-15min, AC does not blow cool air or warm if heat turned up

INCIDENT SUMMARY In February 2025, while driving on the freeway, my vehicle experienced a sudden and complete loss of power. The battery rapidly depleted without warning, causing the vehicle to decelerate dangerously in moving traffic. A Stabilitrak warning appeared on the display. I was fortunate to reach the shoulder safely, but this failure created an extremely hazardous situation that could have resulted in serious injury or death. Following this incident, the vehicle became completely inoperable and required towing to Stewart Chevrolet for diagnosis. DEALERSHIP DIAGNOSIS Stewart Chevrolet performed a diagnostic evaluation (cost: $700) and provided the following official findings: Problem Identified: Battery 1 with voltage variance beyond specifications Variance Measured: In excess of 0.07V discrepancy in battery cells GM Document Referenced: #17-NA-131 Recommended Repair: Labor operation 9102972 - Drive Motor Replacement and Shipping Preparation (high voltage battery replacement) Estimated Cost: $10,000-12,000

Engine stalled possibly due to a faulty fuel pump. I was able to drive the vehicle without issue until I pulled up to my house, when the engine stalled. No warning signs prior to the incident. Proceeded to put the vehicle in park and start the engine again. The engine had trouble starting again, sputtering even when the gas pedal was pressed (no response to the gas pedal). No sound comes from the fuel pump when trying to start. Battery in good condition. Lucky vehicle did not stall while driving down the road at 60 mph. Vehicle will have to be towed to a mechanic.

The 2015 Chevrolet Equinox equipped with the 2.4L Ecotec engine has been reported to have excessive oil consumption due to several issues: Defective Piston Rings: The oil control rings are prone to sticking and clogging, leading to oil blowby and excessive consumption. PCV System Issues: Problems with the Positive Crankcase Ventilation (PCV) system can create excessive vacuum in the crankcase, contributing to oil consumption. Timing Chain Problems: The timing chain can stretch over time, leading to misalignment and potential engine damage. Regular Maintenance: Owners are advised to monitor oil levels frequently and consider using synthetic oil for better performance and longevity. These issues can lead to significant engine wear if not addressed promptly. My vehicle is using too much oil. The 2.4L eco tec engine is installed in this vehicle. The Chevrolet dealership in Rockwall Texas texted me that the engine is bad and needs replacing. The vehicle is past is warranty, so the dealership is using that reason, to not fix this issue. The estimated cost to replace the engine is approximately $11000.00.

The transmission valve has gone bad a few thousand miles outside of warranty. This part has widely been recalled in Silverados up to 2022 but is not including 2024 yet. This is the same issue, that I also had with my Chevy Tahoe last August. Please include 2024 2500 Silverados.

The contact owned a 2019 Chevrolet Silverado 1500. The contact stated that while driving on the highway at approximately 40 MPH, the engine started making abnormal sounds. The vehicle had experienced engine failure. There were no warning lights illuminated prior to the failure. The contact allowed the vehicle to coast to the shoulder and shifted to park(P). The vehicle was towed to the dealer and the contact was informed that the engine had imploded. The vehicle was repaired out of pocket. The manufacturer was not notified of the failure. The failure mileage was 131,000.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while the vehicle was parked and occupied in the vehicle, there was a rattling sound coming from the front of the vehicle while stationary or while driving. An independent mechanic was contacted. The vehicle was taken to a dealer, where it was determined that the exhaust mounts needed to be replaced. The vehicle was not repaired. The contact related the failure to Special Coverage Adjustment: N222385510 (Front Exhaust Pipe); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 118,000.

While driving, the 10l1000 transmission in the truck attempted to shift from 6th gear to 7th gear. The transmission locked up causing a violent "buck" from the rear end of the truck. The road was icy and could have caused the truck to lose control due to the lock up of the rear wheels. After getting the truck to a repair shop, valve body was deemed the cause of the failure. A complete transmission replacement is needed. Had I lost control of the vehicle due to the lock up, my family and other motorists would have been put at risk of severe injury or worse. No warning lights were illuminated prior to failure.