2012 DODGE DURANGO Complaints

While driving our 2012 Dodge Durango in town, we noticed the battery warning light come on and a hot smell coming from the vehicle. We were not far from home so we limped it back home to the garage to see what was going on. When we lifted the hood, there was a very overwhelming burning smell, our alternator was literally glowing red hot, and there was smoke pouring out from around it. We quickly put out the fire and disconnected the battery. Afterwards, we had it towed to a repair shop where it was confirmed the alternator failed as well as fried our PCM in the process. We paid for the install of a new alternator and PCM, however, the radio remained failed. Upon researching this scenario, we found there was a recall for this exact issue for the exact span of years and engine type, however, our VIN was somehow not included in this recall. That needs to be changed. The alternator issue could have been extremely dangerous for our family while in the car, as well as others around us due to what could have happened if the card didn’t make it home. We could have been stranded on a busy road way causing accidents while the car was engulfed in flames due to the alternator. Also, had we not immediately popped the hood at home to check the engine, the car could have burned down our home. We request that the NHTSA and FCA recall company address this issue and the potential for extending the recall to include other Durango VINs.

SRS System light came on. Air bags will not work when this light is on. Safety hazard.

The contact owns a 2012 Dodge Durango. The contact stated while driving at various speeds, the vehicle would intermittently stall upon depression of the accelerator pedal without warning. The vehicle was taken to a local dealer where it remained in their possession for four days; the contact was later informed that the defect was related to the battery. Upon investigation, the contact discovered NHTSA Campaign Number: 19V813000 (Electrical System) which was linked to the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 140,000.

My fairly new teen driver drove the car to the gym and the headrest basically “exploded” onto the back of his head with a swift blow. He had a very bad headache and was really freaked out. There were no lights, no notice, no impact. Just out of the blue drivers side. Called local dealership to see what it could be and apparently the pin can break or the plastic holding the pin and the airbag restraint type system in the headrest will just explode open as if in an accident. He said no recalls and out of warranty. How can this NOT be a serious safety issue??? My inexperienced teen driver could have been so stunned he caused an accident! Anyways they said it would be roughly $1100 to replace entire headrest because there is no option to repair it once deployed. Can we still drive it? If we don’t have that $ now

Headrest exploded while I was driving. Hit me in the head. Gave me a concussion. Dealership says there is no recall. I have to pay out of pocket. This is a safety feature. I am not paying for the repairs.

While picking my son up from religion my vehicle suddenly stalled without warning. Thankfully I was pulling into the church parking lot and was in no real danger. I tried to jump start the vehicle with no success, but did notice the insulation on the jumper cables had started to melt. Towed to mechanic and was told the alternator had failed, in turn fried the battery. He replaced both, but then discovered the PCM was fried as well. Took it to the dealer here and was told faulty alternator again, which was replaced again, only to be told the PCM was fried. Now I'm into this for $3000 and I have no faith in the vehicle, the manufacturer, or the dealerships.

The 2014 through 2018 3.6L Pentastar motors are covered under a tech service bulletin for their Drivers side valve train being manufactured incorrectly. This can lead to a misfire and hesitation to accelerate in an Emergency. This happened to me recently and I thought it was just a bad spark plug. Mechanic did a full check and believes there is a stuck valve in the engine on the exact same side that the 2014 to 2018 motors are prone to failure. I believe the 2012 and 2013 Engines are also prone to the same failures as their newer counter parts. As I was trying to accelerate to avoid an incident my car stuttered and started to misfire badly. Almost causing a collision. This happened without warning and never previously had this issue. Vehicle was completely mechanically sound before this. This can happen without any warning or signs its going to happen. And after bringing the vehicle to a mechanic and doing much of my own research it appears that the drivers side of the 3.6L v6 in my vehicle is currently under a TSB for the #2,4,6 cylinder head. This can cause the vehicle to have no power for a moment which if I were merging onto the highway and lacked powered could result in a rear end collision. Believe this is a safety issue as well as mechanical issue.

I bought this vehicle second hand and was not warned of any recalls. I started having problems in April of 2023. Windshield wipers would turn on by themself, car would randomly shut off. I brought to several shops and nobody could figure out why it was reading “high voltage”. The car then started having occasional problems shifting. I eventually got on MOPAR website to be made aware there were 3 recalls and alternator was one of them. I called musson patout dodge in new Iberia, LA and made an appointment to fix my car. On the morning of our appointment the car died in the road on the way to dodge and wouldn’t restart without a jump. I brought it in and over the son of 3 days the fixed all the recalls. On my way to pick it up they called and made me aware it would need a new battery I told them I will go replace it as soon as I get the car. Since I picked up the car the shifting problems have not stopped. I have had a code reading “implausible data from tcm”. I have had a mechanic TELL me this recalled alternator going out is what cause this tcm to go out and Musson REFUSES to take it in and even diagnose it without over $170 that I don’t have to spend anymore. This is consequential damage that dodge should be held liable for and they are giving me the most difficult time, it’s my only vehicle for me and my 2 kids and I cant even drive it anymore.

When i am driving around out of nowhere it will try to go into Low range when it is in auto Awd and low light will flicker on the dashboard

Engine stops after 2-3 seconds of running. Need to turn off and try again. Happens randomly at startup.