2023 HYUNDAI IONIQ 5 Complaints

Several days ago, the twelve volt battery on my car was replaced because the car just suddenly died overnight while sitting in my garage. They told me that the battery needed to be replaced when I went to the dealer. They replaced it and now less than a week later, I was driving on the highway and suddenly the car Slowed to no more than 27 miles an hour with warnings about the electrical system not working and a problem with the battery. I had to put my flashers on while I was driving down the highway until I was able to pull off and have the car towed to another dealer that was closer to the scene. Not sure what they are going to say, but obviously this was very scary as well as a nuisance.

I was sitting in my parked vehicle, which I had just turned on. It was cold so I turned on the seat warmer. About a minute later, I hear a pop and saw a “check electric vehicle system” warning on my dash, followed by an audible alarm and a new “stop vehicle and check power supply” warning on the dash. I decided to have the vehicle towed to my local Hyundai dealer.

While driving on a 45 mph speed limit road, there was a "pop" noise and then alarms on the dash display that power was limited and stop the car. The car's speed was severely limited to about 10 mph for a few seconds while I pulled the car over, and then the car died. Everything was electrically dead. I couldn't even turn on the hazard lights or lock or unlock the car. I took a video of the dash display rapidly alternating between two alarm messages, "12V battery storage low. Stop safely." and "power limited." This website wouldn't let me upload the video, so I saved screen shots of the two alarm messages from the video. Shortly after I stopped the car, it all went dead. It scares me to think what would have happened if I had been on the interstate when this occurred.

I was driving the car 70 miles per hour in a highway. Car suddenly stopped and only go 5 mph. I was lucky no car behind me. If not I could be death today. I brought it to service and ICCU unit failed which is happened almost all Hyundai IONIQ 5. They replaced it with same ICCU and it will happen again. I think they want me to make an accident next time. This car is not safe to drive with this charging unit.

We were driving our vehicle in a parking lot while on vacation and we got an error message “check electric vehicle system”. It then displayed the error message “stop safely and check power supply”. Four months ago, we had the same problem and had our 12 volt battery replaced and our ICCU updated. Our vehicle lost power while we were driving. We were able to drive the car safely to a hotel. But the ICCU needs to be replaced.

The ICCU failed, leaving the car with a Check Electrical System failure and ultimately cutting power to the vehicle, forcing driver to pull over and stop.

My new 2023 IONIQ 5 became inoperable on 3 occasions when it completely lost power. This situation unquestionably impaired my safety on the first occurrence of power failure that happened without warning while I was driving; fortunately, I was able to coast to the side of the road without incident. In my repair visits to Hyundai dealers, the integrated charging control unit (ICCU) updated (twice) and the depleted 12-volt battery was charged. Repair visits resulted in loss of use of my car for a total of 31 days while it was in service. The 12-volt battery finally had to be replaced on the last dealer visit because it had could not hold a charge. The battery was barely a year old. No Hyundai dealer could assure me that the problem with the charging system was resolved. It was suggested that annual replacement of the 12-volt battery before the end of its normal lifespan might be required to avoid the serious safety risk of power failure while operating the vehicle. Hence, I am not driving my car with confidence that the safety risk risk was alleviated. I understand that Hyundai Motors acknowledged the ICCU problem and addressed it with a new ICCU in the 2025 Ioniq 5 model year. However, in my case, I have a still-new, expensive vehicle that I drive without feeling 100 percent secure that I am safe.

I started my car and after a minute I received a warning saying to check my electrical system and safely pull over. After 5 minutes of trying to drive to the dealership the car suddenly slowed down to a max speed of 27mph and then shortly after slowed to a stop and turned off. The car would not turn on and eventually the 12v battery died. I tried to jump the car but the 12v would not stay charged long enough to put the vehicle into drive. It appears the ICCU is not working and cannot keep the 12v charged to make the car function .

Car lost power due to electrical supply--12v/ICCU failure. Warning on dash instructed me to stop vehicle immediately. Car is currently at dealership and inoperable.

The lower control arm broke off of the subframe during daily commute on the highway, which left the car completely immobilized and had to be towed. The incident could've been a lot worse if I had lost control of the car and swerved into others on the road. vehicle is currently being inspected by Hyundai dealership. Prior to the incident, there were no warning lights or symptoms.