2023 HYUNDAI IONIQ 5 Complaints

The contact owns a 2023 Hyundai Ioniq 5. The contact stated that while driving on the freeway, the vehicle shut off unexpectedly. The vehicle was coasted to the side of the road and parked. Moments later, the vehicle was restarted, and the vehicle drove normally. The contact stated that the failure had reoccurred on several occasions, and the vehicle was taken to the dealer each time, but the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 4,000.

We are reporting a suspected thermal runaway incident involving our recently purchased used 2023 Hyundai Ioniq 5 and have significant concerns regarding the vehicle's safety. **Vehicle Information** * Purchased XXX, 36,662 miles * Clean inspection and no accidents per Carfax **Incident Timeline – XXX** Between 6:00 and 6:30 PM, while traveling northbound on [XXX] just past the [XXX] exit in [XXX], the vehicle struck a white piece of road debris that appeared flat, similar to Styrofoam (video available). There was no immediate loss of vehicle function. [XXX] The vehicle was then moved to the driveway for inspection after a low coolant warning appeared. Damage to the underside near the driver's side and observed blue coolant leaking from the area. The coolant reservoir under the hood was empty. Based on online guidance advising against driving a vehicle with a coolant leak, we decided to leave the vehicle parked in our garage overnight and arrange a flatbed tow to a Hyundai dealership the following day. The garage door was closed, and the vehicle was **not charging**. At approximately 8:10 PM, a burning smell was detected inside the home. Upon opening the door between the house and garage, smoke was observed. The family immediately evacuated, and XXX was called at 8:12 PM. The fire department arrived at approximately 8:18 PM and found the garage filled with smoke. At 8:30 PM, firefighters removed the vehicle from the garage. At 8:35 PM, flames were observed beneath the vehicle. Firefighters applied water directly to the fire until 11:00 PM, after which the vehicle was removed. [XXX] [XXX] [XXX] Manufacturer was contacted; denies any liability due to debris. However, we believe inadequate safety design contributed, including soft protection shield and poor location of coolant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The ICCU malfunctioned. Safety impaired because it likely impacted the ADAS, which concurrently failed. Yes, the problem has been inspected and confirmed by a dealer.

There is a yellow air bag (SRS) safety restraint critical wire harness underneath the seats and it's loose and hanging down touching the floor with lots of slack, very easy for a water bottle or any object to roll under there and pull it loose, which would disable a critical passenger safety system. This issue is reported by many drivers including myself, photos attached are from multiple people's experiences with this issue.

The vehicle repeatedly displays a "Stop Vehicle and Check Brake System" warning together with an ABS warning, accompanied by a loss of normal braking response. On XXX, while driving at approximately 60 mph on I-85 northbound near Exit XXX in [XXX], the warnings appeared and the brakes did not respond normally. I was maintaining a substantial following distance, and the braking system restored itself before I reached the point of needing to brake hard, so no crash or injury occurred. Had hard braking been required in that window, I do not believe the vehicle would have stopped as commanded. This is a recurring fault. The vehicle, purchased certified pre-owned and still under the Hyundai factory warranty, has been taken to the dealer (Ed Voyles Hyundai, [XXX]) three times for the same condition. On the first visit the Integrated Electronic Brake (IEB) unit was replaced; on the second, the Smart Junction Box was replaced; on the third, the dealer removed an aftermarket tracking device wired to the data link connector and referenced Hyundai TSB 24-GI-011H, representing the problem as corrected. The braking-loss event on XXX occurred after that repair. The vehicle has been out of service approximately 30 days total. Because the failure is an intermittent loss of braking response at highway speed, I consider it a serious safety hazard and no longer drive the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Hyundai Ioniq 5. The contact stated that while driving at higher speeds occasionally, the vehicle suddenly lost motive power. The "Smart Smooth Cruise Control Conditions Not Met" warning message was displayed on the instrument panel. The contact restarted the vehicle as a temporary fix; however, the failure recurred. The vehicle was taken to a local dealer where it was diagnosed with an unknown electrical failure. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the same local dealer; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

Rear hatch window spontaneously shattered for no apparent reason. Car was parked in a Florida parking lot, no use of rear hatch and no use of rear defroster. I understand there is a potential class action lawsuit for the Ioniq 5 model years 2022-2025 for this problem.

The ioniq 5 highway driving assist, which steers the car and keeps it centered in the lane, will disengage without clear warning - the small green steering wheel icon (which is at the top of the dash cluster) simply becomes grey and blinks, but there's no audible chime to indicate that the car has disengaged the steering assist. I have had multiple times on the highway where it disengaged and I don't notice (because I am looking at the road, not the dash) and one time on the highway it disengaged during a turn and hit the rumble strip, causing me to swerve back onto the road. My hands were on the steering wheel and I was paying full attention, but I was expecting the car to handle the turn, and it just disengaged without me noticing. Had there been another car in the middle lane or I reacted slower, it's likely a crash would have occurred. This has been documented as well on Reddit and confirmed by multiple owners, who have mentioned they have disclosed to the manufacturer: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have a 2023 Hyundai Ioniq 5 Limited and had the ICCU "popped" (failed) which took about two weeks to replace. This time we were lucky that in happened at our home but had we been driving the car would it would have completed died. We regularly drive from from [XXX] to [XXX] were there are large section of [XXX] with no cell service. Meaning potentially walking for miles in extreme heat or cold. Hyundai right now seems only interested in continuously replacing the part rather than actually fixing the route cause, making it so the car is not trustworthy or safe to drive long distances. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1. What component failed, and is it available for inspection? The Integrated Charging Control Unit (ICCU) failed. The vehicle is currently at the dealer's service center, so the failed component is available for inspection upon request. 2. How was your safety or others' safety put at risk? After parking and re-entering the vehicle following a grocery stop, the vehicle displayed "Check Vehicle Electrical System" followed by "Check Vehicle Power Supply" warnings. This occurred without warning while the vehicle was in normal use, and the vehicle had to be towed since it was no longer driveable. The sudden, unannounced failure of the electrical/power system created a risk of being stranded in traffic or in an unsafe location had the failure occurred while driving rather than while parked. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The vehicle was towed to the dealer's service center, where the Hyundai-certified service technician confirmed the ICCU failed and informed us it needs replacement. 4. Has the vehicle been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by the dealer's Hyundai-certified service technician, who confirmed the ICCU failure. No additional inspection by Hyundai corporate, police, or insurance representatives has occurred at this time. 5. Were there any warning lamps, messages, or other symptoms prior to the failure, and when did they first appear? No warning lamps or messages appeared prior to the incident. The first symptoms were the "Check Vehicle Electrical System" and "Check Vehicle Power Supply" messages, which appeared suddenly upon re-entering the vehicle after a grocery stop, approximately one week after purchase (used) at roughly 8,000 miles.