2023 HYUNDAI IONIQ 5 Complaints

Charging prematurely terminates before completed. Dealer denies knowledge of this. However suggested charging at "reduced" as opposed to "maximum" level. Even charging at "reduced" setting, charging still terminates before complete.

Cruise control became disabled and then unable to accelerate when pressing down on accelerator

Occasionally, the vehicle sometimes doesn't start and allow me to engage to Drive gear from being turned off/Parked. I sometimes have to turn the car off and back on 1-2 times for the car to start like normal and allow me to select drive or reverse. Additionally, I have never been able to successfully sync my vehicle with my hyundai bluelink account despite efforts to troubleshoot with Bluelink representatives.

Sometimes, the batteries trip while charging and don’t recharge, don’t charge at the expected speeds, or only charge partially. Recently, when charging at home all night and plugged into our Level 2 charger, I find find that the car has not charged at all overnight.

When starting vehicle, presents a warning message in instrument panel of "Check electric vehicle system". The stated description indicates: "This warning message is displayed when there is a problem with the electric vehicle control system. Refrain from driving when the warning message is displayed." This could be an issue with the battery system, or steering system that puts others in danger due to the unpredictable nature of the error. The Hyundai app that reports vehicle statuses does not show any error or diagnostic codes.

Vehicle is supposed to be able to charge at 48A on an AC charger but it does not do this during the months when ambient temperatures are above freezing. Poorly designed thermal management by the manufacturer causes charging to stop when the local temperature at the charge port door exceeds the threshold. The only way I can charge this car at home outside of the winter months is to lower the EVSE amperage to 32A which results in the car taking longer to fully charge than it’s supposed to. This car is supposed to be able to AC charge at 11.5 kW with 48A but it simply cannot do that most of the time. This issue is widely reported on the Ioniq 5 forums and is not isolated to me.

Twice this week while charging my Ionic 5 the charging stops before it is completely charged to the set point. Once the set point was at 80% and once at 100%. Both times the charging stopped and I received the message below. None of the reasons listed in message was a cause of the stopping. I have called my dealer and they are checking w/service dept to see if I need a software update. I am waiting to hear back but there is obviously something wrong with the rate of charge. I am using a Jukebox home charger.

When AC charging my car, It quickly overheats and disables charging. I've measured the temperatures at 239°F using OBD reader. The only way to continue charging is to reduce charge amperage. If it is reduced to 32 amps the temperature seems to stabilize before reaching the 240° emergency cut off.

EV goes into power limited mode when on interstate when going ~50 miles while driving 70mph or more. Happened each of my 3 times on interstate of about that distance. First time was Sat 4/29 while in eco mode with 70% battery and 82°F outside, 1 hr drive 50+ miles. Second time was in normal mode Friday 5/12, 55% battery 72°F outside 1 hr drive 50+ miles. Third time was in normal mode and it happened after 42 miles. I scheduled a service after the first incident but they were only able to take it on 5/31. When this happens you lose ability to accelerate and have to coast to the side of road and let it sit for 10+ minutes to clear and then can resume, I would take surface roads after it occurred. Impacts safety for self and others, as it drastically slows without brake lights causing a high chance of being rear ended. The last incident was close to it. As it was getting worse I stopped driving on interstate with it. Car has been at the dealership's service department since 5/31. They were able to easily reproduce once they finally got to it. They diagnosed a bit and then consulted design engineers. Diagnosed on and off for a couple weeks and have finally decided to replace the drive motor. Part received Friday 6/16, to be installed tomorrow 6/20. We'll see if that addresses.

The charging system in the 2023 Ioniq 5 has multiple issues with connectivity and charging above a certain threshold. When charging at home using an electrician certified install by Merit and a county approved installation and Emporia EVSE 48A charger, the car prompts with a message that reads "Electric Vehicle Charge Alarm was processed. Your vehicle is not charging because of a connection failure. Possible reasons include: blackout, payment incompletion, charging stop button enabled." This has only recently started happening with the temperature in the closed garage reaching above 80F. The only way to rectify is to charge below 40A and this same issue is being reported by other Ioniq 5 owners via online forums as well. As it relates to DC fast charging at public infrastructure, the Ioniq 5 has a reliability problem with connectivity to the CCS1 ports that are used with Electrify America stations. The common denominator appears to be the charging port of the Ioniq 5.