2023 HYUNDAI IONIQ 5 Complaints

While driving on the interstate my 2023 Ioniq 5 SEL RWD experienced a failure with the front radar system stating that it was blocked. In reality there was nothing physically blocking the system which was verified on multiple pullovers to check the front of the vehicle. This caused the critical forward safety functions, HDA system, lane change assist functions, regeneration system, and smart cruise control to all be disabled. The car is available for inspection upon request and I have video of the car displaying the fault messages during the trip as it happened on multiple occasions.

We purchased our 2023 Ioniq5 approximately 7 months ago. We saw an article in the newspaper about the 2022 Ioniq losing power while driving. That has happened to us 3 times in the last several months so it is not strictly the 2022 model. One time was particularly scary as I was entering a busy freeway the car lost power and as much as I pushed on the pedal I could not go more than 20mph. This happened for about 15-30 seconds then finally accelerated. My husband said he has experienced the same problem with this vehicle on 3 different occasions. Thank you.

2023 Hyundai Ioniq 5 (SEL, AWD) has bad ICCU (intergrated charging control unit). Will only charge at DC chargers reliably, level 2 or level 1 chargers will only work intermittently. Has been in the shop 2 weeks with no estimated repair date as the ICCU is on backorder. This issue is affecting a lot of Hyundai/KIA/Genesis customers who's vehicles share the same platform. The dealer won't even say where I am in line to receive the ICCU vs. everyone else in North America. This is really unacceptable for a car I paid almost $60,000 for.

The charging port on the electric vehicle appears to have poor cooling as the port frequently overheats when connected to any level 2 charger that is within the vehicle's approved specs. I've measured it going as high as 200 degrees F before the car stops accepting a charge, and even after that the port will remain piping hot until it is physically unplugged. This is quite dangerous as I mostly charge at night and am asleep when it happens in my garage. A quick search online shows that hundreds of Ioniq5 owners are having the same issue. Hyundai released a technical service bulletin(23-EV-003H), so I can take it into a dealer for a software update that will fix the issue. However, that update only succeeds in restricting how much current the car will accept in order to keep the temperature within safe levels. This means that the car I purchased cannot function safely as advertised.

What component or system failed or malfunctioned: Rear electric motor. Specifically the "engine oil pump" that is used to cool the rear motor. The pump does not respond to MCU commands and does not cool the motor. This causes the motor to overheat after about an hour of highway driving causing the motor to provide VERY limited power. How was your safety or the safety of others put at risk: When the above happens the car experiences a delayed throttle, and very little power to accelerate. This occurs while traveling on a highway where you may need to pass, but no longer have the power to do so safely. Has the problem been reproduced or confirmed by a dealer or independent service center: Dealer took the car in and did not properly attempt to reproduce the issue. Then stated that if the car does not produce a DTC then there is no issue. The dealer has since refused to accept the car again. This has been reproduced here: https://www.ioniqforum.com/threads/rear-motor-not-operating-45-min-after-charge.46007/ Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others: No, I have just started the process of reaching out to the manufacture, and if this fails I will be using my states lemon laws. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear: No this issue does not appear to throw any codes, lights, or messages. The dash shows the rear engine producing no power, and the throttle will only show half when pressed to the floor.

12v battery died within 6 days and needed to be jumped. Another 4 days and the 12v will not hold a charge at all. This is a new 2023 Ioniq 5 Limited AWD. Odo on the lot was 13 miles. Odo at 10 days was around 280. Waiting to hear from Hyundai, but dealer confirmed 12v is bad. Currently unknown if ICCU is also faulty.

brake lights do not come on when the car is in regenerative braking or driving mode and the driver is touching the gas pedal. Drivers following the car are not aware the car is actually braking not coasting. This is causing a rearending hazard. Mfr needs to correct issues so brake lights come on when car is in regenerative braking mode and the car is deaccellerating regardless of gas pedal activity

The Ioniq 5 has a braking system that does not engage the brake lights on deceleration when in certain regenerative braking settings. This is dangerous as the car will quickly decelerate and not warn drivers behind you potentially causing a crash because they are unaware the Ioniq is stopping quickly. Please have Hyundai address the issue for recall.

The Ioniq 5 when using level 2 regen, level 3 regen, and i-pedal (one pedal driving), does not turn on the break light when decelerating, even if coming to a full stop unless the driver removes their foot completely from the pedal or hits the break pedal. These driving modes allow the driver to perform regenerative breaking almost to a complete stop without turning on the break lights and warning other drivers behind you. With i-pedal specifically, the driver can 100% perform all stop and go traffic maneuvers without using the break and never have the break lights activate. This appears to be the default behavior of all Ioniq 5 vehicles and is controlled via software. The vehicle does not appear to measure rate of deceleration so even if the driver were to decelerate rapidly, the brakes would not activate. This has been extensively demonstrated on youtube and the best video example of this problem can be found here: https://www.youtube.com/watch?v=U0YW7x9U5TQ

The brakes lights do not illuminate when slowing down using regen braking. This has cause cars to stop very close to rear-ending me. This video explains this issue in great detail https://www.youtube.com/watch?v=U0YW7x9U5TQ