2023 HYUNDAI IONIQ 6 Complaints

The Integrated Charging Control Unit (ICCU) failed in November 2024. Instrument panel warning indicated an electrical failure and that the vehicle should be stopped immediately. The Hyundai dealer identified Diagnostic Trouble Code (DTC) P1A9096 and per Service Campaign 997 Technical Service Bulletin 23-01-060H replaced the Integrated Charging Control Unit (ICCU). In December 2024 Recall 272 TSB 24-01-086H software upgrade installed to further address Integrated Charging Control Unit (ICCU) failure.

March 21st at around 7:30 PM, I was driving on the highway when my panoramic sunroof suddenly exploded—or shattered—completely out of nowhere. It was a clear night, no rain or debris, and there were no cars directly in front of me. Nothing hit it—no rocks, no objects—just a loud bang, and the glass was gone. I’ve got photos of the damage (attached), and it’s clear this wasn’t caused by an external impact. The glass blew outward, which makes me think it’s a manufacturing defect or stress in the material. Thankfully, no one was hurt, but this is a major safety issue.

There are 2 horns; a high tone and a low tone. The low tone horn failed, making the horn sound difficult to hear. This same issue has been reported by many Ioniq 6 owners. I scheduled an appt w/ a Hyundai dealer and the defective horn was replaced. This happened when the vehicle had less than 3,000 miles.

The horn on my vehicle is defective after 16000 miles. I am available to take it in for an inspection. I was almost backed into and I had no way of alerting the other driver. This problem has not been reproduced by my local dealership but it has been at other national and international dealerships per forums. I am unsure if this component has been inspected by the manufacturer, police, insurance company, etc. This problem was random without warning which makes this even more of a safety concern since I had no clue this was defective until I actually had to use it.

Shortly after the ICCU recall was repaired I received numerous electrical system warnings on my Hyundai Ioniq 6 (2023, SE model). The dealership identified the problem to be the Battery Management System needed a complete replacement would you take 1-2 weeks. When you factor in three different ICCU service appointments (two SW updates and full replacement) the BMS issue was the fourth electrical / battery issue in the 16 months I've owned the vehicle. Purchased Sept 20, 2023 and have 40k miles.

The ioniq 6 horn is a two (2) tone horn. First, one (1) of the tones went out (lower tone). Now, the horn completely doesn't work. Reading online, this is a common issue with the 2023 & 2024 ioniq 6. This is the same horn (car is the same platform) as the ioniq 5, and lots of forums online also have people posting about their horns going out and not working at all.

4 days after having recall 272 performed by the dealer the ICCU on the vehicle failed. Warning lights indicated failure and to stop the vehicle. Luckily, only 1 mile from home and drove it home under reduced power . Called the dealer (70 miles away) and was told to tow the car to them. Car was diagnosed with ICC failure. Replacement had to be ordered but might take at least 4 weeks.

While driving, "check power system" warning appeared on this 2023 Hyundai Ioniq 6. Moments later an alarm sounded advising to stop driving and turn off engine. I was able to drive to a safe place although the vehicle would not accelerate beyond approximately 15 mph. Car was conveyed by carrier truck to dealer where as of this date it has remained for two weeks as the service department awaits parts. Note: all prior software updates/recalls had been completed before this unfortunate incident occurred.

The dashboard error code (check vehicle power supply) also in the bluelink app the error code(DTC P1A9096). I was driving the car. It was 196 miles of range. The car suddenly went into turtle mode and then the car just died in the middle of the road. Luckily I was outside my residence. After waiting 4 hour for towing. I had it towed to the dealership.

Horn stopped working 18 months into owning the car. Numerous other drivers report the same issue.