2022 MERCEDES-BENZ GLE 350 Complaints

I was told by the investigators that the fire was caused by an electrical component under the passenger seat that Mercedes is well aware of. My life was placed in danger because of the Inhalation of forever chemicals and lung damaging smoke and super heated air. Problem confirmed by dozens of owners who experienced and documented the very some accounts, some who have reported contacting the NHTSA years prior to my experience but nothing was done to save lives or prevent losses. The American Freedom insurance investigator told me in writing what caused the fire. Nothing gave any indication that my life was in danger not a light, an alarm nor the monthly Connect service I paid for every month. Nothing gave me an indication that something like this was going to happen.

For approximately two years, I reported recurring moisture/condensation inside the RIGHT headlamp assembly of my 2022 Mercedes-Benz GLE 350 to Mercedes-Benz. I was repeatedly advised that the condensation was normal. The condition progressively worsened. The vehicle is now displaying headlamp warning messages and the RIGHT TURN SIGNAL associated with the affected headlamp is no longer functioning. I am also receiving repeated warning messages related to the headlamp/turn-signal malfunction. The loss of the turn signal creates a safety concern because I cannot reliably signal my intention to turn or change lanes to other motorists. Mercedes-Benz has now advised that the headlamp assembly requires replacement. The affected component is the RIGHT headlamp. For completeness, the vehicle previously sustained an unrelated sideswipe on the LEFT side, during which the LEFT headlamp was scuffed and replaced through insurance. There was no frontal collision, and the present moisture intrusion and signal failure are occurring in the RIGHT headlamp on the opposite side of the vehicle. I am reporting this to NHTSA because a condition Mercedes-Benz previously characterized as normal has progressed from condensation inside the headlamp to warning messages and failure of a safety-related signaling function. I am concerned that similar moisture intrusion in this headlamp assembly could affect other vehicles.

while driving, vehicle issued alerts for inoperative active brake assist, inoperative distance control, inoperative blind spot assist, and inoperative active stop and go assist. with all those alerts it was very concerning and I felt apprehensive to operate the vehicle further, as it may crash. Mercedes Benz dealer technician confirmed that the Distronic and Cruise control unit was defective/faulty.

The contact owns a 2022 Mercedes-Benz GLE350 4Matic. The contact stated that while driving approximately 35-40 MPH and depressing the brake pedal, several unknown warning lights illuminated, and the vehicle jerked and lost motive power. The contact pulled over to the side of the road until the vehicle stopped. The contact stated that the failure had occurred on several occasions. The vehicle was taken to the dealer, where the accelerator pedal wiring harness and loosened pin segments were replaced; however, the failure recurred three days later. The vehicle was taken back to the dealer, where unknown repairs were performed; however, the failure persisted. The vehicle was taken back to the dealer, but was not yet diagnosed or repaired. The manufacturer was notified of the failure, a case was filed, and the manufacturer partially covered the second repair. The failure mileage was approximately 86,882.

On July 7, 2026, my 2022 Mercedes-Benz GLE 350 experienced a serious engine malfunction. After stopping at a traffic light, the engine began shaking violently and idling roughly. When the traffic light turned green, the vehicle accelerated extremely slowly and had very little power, making it difficult to clear the intersection. The engine continued running roughly, and I was concerned the vehicle could stall in active traffic. At the same time, the ECO start/stop system automatically disabled itself and displayed "OFF" in white on the instrument cluster. Because the vehicle appeared unsafe to drive, I had the vehicle towed to Mercedes-Benz of San Jose on July 8, 2026. The dealer confirmed the rough-running engine condition and advised that the cylinder head ("engine top") must be replaced. This incident occurred after three repair attempts for recurring engine-related check engine light faults within approximately six months: 1.January 23–28, 2026: Check engine light illuminated. Dealer diagnosed fault in motor electronics for code P240200 (Actuation of the pump in the diagnostic module of the evaporative emission control system has a short circuit to positive). Separated diagnostic module from charcoal canister. Replaced. Cleared codes. System OK. 2.May 13–26, 2026: Check engine light illuminated again. Dealer diagnosed fault code P260F00 (monitoring of the evaporative emission control system has a malfunction). Multiple diagnostic tests were performed. All OK. Evap system OK. No replacements of parts before the vehicle was released. 3.July 4, 2026: Check engine light illuminated for a third time. On July 7, the engine began running extremely rough while stopped at a traffic light, causing a significant loss of power and severely limited acceleration. The vehicle was subsequently towed to the dealership. I am submitting this report because the recurring engine malfunction has progressed to a sudden loss of power in traffic, creating a potential safety hazard.

Incident 1- on several occasions the screen went blank on my dashboard where I could not see the odometer and important information. This has happened on several occasions and sometimes happen to wait until the next day in order for it to come back on Incident 2- car is now in the dealer for engine issues and rattling sound once started. Needs to restart before sound stops

Rear bumper valance fell off while driving. Unsure where it occurred, but it did happen on freeway most likely. Thinking must’ve been something wrong with the clips. Car is only four years old.

Front Stationary Sunroof Panel with a panoramic sunroof, the stationary panel located between the windshield and the panoramic sunroof cracked and ultimately shattered. Needed removal of the bonded panel and installation of a new front panel. There was a RECALL CAMPAIGN BULLETIN 2021070010 issued August 2021 but did NOT identify problems for SUV's having later year models such as 2022 GLE. The panel is not available for inspection as it has been replaced Friday, February 13, 2026, by Safe Tech Auto Glass with costs born by owner. There are photos before replacement on my phone, but not on desktop computer. Star Motor Cars, Houston, had identified the problem saying it was the same as the RECALL for earlier year models. Spoke with Mercedes Benz Customer Service on February 09 and 10, 2026. No satisfaction for 2022 GLE model.

When I got gas the estimated range indicated 308 Miles. We traveled approximately 134 Miles the estimated range was at 86 Miles it was dropping rapidly but average miles indicated 26.5 MPG. The next day we added fuel again and we were at 382 Miles. Then we drove 70 miles and the fuel indicator was showing that our range only decreased 15 Miles. During the trip the range increased multiple times and between the two days we traveled we did not know how much fuel was left in the car. The first trip it showed that we burned half a tank and the second day it showed we hardly burned any gas. This particular model has Open Recall for fuel pump system issues and display software. We were afraid that we were running out out of gas and would not be able to complete our trip or run out of gas in the middle of the highway.

Check engine light came on. Called dealership on a Thursday and again on Monday after it stayed on all weekend. Was told to bring in vehicle for diagnostics and to have a ride home. Half way to the dealership the car spuddered and I had to coast to the shoulder of the road. After a few minutes, I restarted the vehicle and drive slowly to the dealership, barely making it it the shop. The service advisor indicated it could be the cylinder head even before running diagnostics because it had happened to numerous other customers. It was a defective cylinder head. The repair bill was over $10,000 but Mercedes offered a $3,500 assistance credit. After doing some research on the internet, this appears to be a widespread issue.