MINI Complaints

POWER STEERING COMPLETELY QUIT WORKING. CAR WAS VERY DIFFICULT TO STEER. STOPPED AND TURNED OFF CAR FOR A WHILE. STARTED CAR AGAIN AND POWER STEERING WAS OK. NOW POWER STEERING IS VERY DIFFICULT UNTIL CAR HAS BEEN RUNNING FOR A FEW MINUTES. *JS

TL* THE CONTACT OWNS A 2006 MINI COOPER S CONVERTIBLE. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG SENSOR WAS CONSTANTLY ILLUMINATED. THE DEALER STATED THAT THE SENSOR MALFUNCTIONED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

COLD START KNOCKING NOISE, AFTER DRIVING OUT MY LOT THE ENGINE WILL SUDDENLY TURN OFF AND HAVE TO START UP AGAIN. RATTLING SOUND CONTINUES.... *JS

WHILE DRIVING AROUND TOWN THE POWER STEERING QUIT WORKING MAKING THE CAR VERY HARD TO TURN. IT WAS NOT NOTICEABLE DRIVING STRAIGHT, BUT WHEN TAKING A LEFT OR RIGHT TURN YOU ALMOST CANNOT MAKE THE TURN UNLESS YOU REALLY CRANK ON THE STEERING WHEEL. THIS PROBLEM HAS BEEN HAPPENING INTERMITTENTLY WITHOUT NO WARNING. IN ORDER TO GET THE POWER STEERING BACK, THE IGNITION HAS TO BE COMPLETELY SHUT OFF, AND THEN RESTARTED. *TR

LOUD NOISE/RATTLE AT IDLE. LOOSE CAMSHAFT TIMING CHAIN DUE TO TENSIONER FAILURE. IT WOULD APPEAR FROM SEVERAL FORUMS THAT THIS IS FAIRLY COMMON PROBLEM THAT DEALERS ARE REFUSING TO FIX SINCE WARRANTY IS EXPIRED. *TR

PASSENGER SIDE SEAT OCCUPANCY SENSOR FAILED, AIRBAG LIGHT AND PASSENGER OCCUPANCY LIGHT ARE ILLUMINATED. COST TO REPLACE IS AROUND $1K. THERE WAS A RECALL OF THIS FOR MODELS UP TO 2005, BUT THIS MODEL IS NOT INCLUDED. *TR

TL* THE CONTACT OWNS A 2004 MINI COOPER S. THE CONTACT NOTICED THAT THE VEHICLE'S AIR BAG WARNING INDICATOR WAS CONSTANTLY ILLUMINATED AND BOTH FRONT WINDOWS HESITATED TO ROLL UP AND DOWN. ALSO, THE AIR BAG INDICATOR WOULD ILLUMINATE WHEN THE FRONT SEAT BELTS WERE BUCKLED OR UNBUCKLED. THE DEALER STATED THAT THERE WAS A POSITIVE CABLE IN THE FUSE BOX THAT MALFUNCTIONED. THE CONTACT WAS INFORMED THAT THE FAILURE COULD DESTROY THE ELECTRICAL SYSTEM, CAUSE A FIRE, AND KEEP THE AIR BAG FROM DEPLOYING IN A CRASH. THE SEAT BELT BUCKLES WERE REPAIRED, BUT THE FAILURE RECURRED. THE DEALER ALSO DISCOVERED THAT THE CABLE WAS BEING STRETCHED AND THE CENTER SWITCH PACK CASE WAS SEPARATED, WHICH COULD CAUSE THE WINDOWS TO DETACH FROM THE VEHICLE WHILE DRIVING HIGH SPEEDS. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 124,500.

DURING LIGHT ACCELERATION AT INTERSTATE SPEEDS, THE ENGINE LOST SOME POWER AND THE SERVICE ENGINE LIGHT CAME ON. THE DEALER FIRST REPLACE THE VACUUM HOSES. IT HAPPENED AGAIN, THE DEALER REPLACED THE VACUUM PUMP. IT HAPPENED AGAIN IMMEDIATELY, THE DEALER REPLACED THE TURBOCHARGER UNIT BECAUSE THE WASTEGATE WON'T CLOSE COMPLETELY. THE TURBOCHARGER AND WASTEGATE SHOULD LAST MUCH LONGER THAN 5 YEARS (THE CAR WAS DELIVERED IN APRIL 2009) OR 70,000 MILES. *TR

MY PROBLEM IS WITH A 2005 MINI COOPER S. WHY IS THEIR NOT A RECALL ON THE WATER PUMP? IT HAS BEEN KNOW FOR GOING OUT PREMATURE AND BMW HAS REDESIGNED THE NEW PUMPS WITH A METAL IMPELLER INSTEAD OF PREVIOUS PLASTIC. TALKING TO THE DEALER, THEY MADE ME FEEL FORTUNATE THAT MY WATER PUMP MADE IT TO 50,000 MILES STATING THEY REPLACE MANY WATER PUMPS IN THE 1ST GENERATION SERIES AROUND 20,000 MILES. I STRONGLY BELIEVE THIS IS DANGEROUS, AS THE FAILURE CAN CAUSE OVERHEATING AND REQUIRES YOU TO SHUT OFF THE CAR, AND SIT ON THE SIDE OF THE ROAD. CARS ARE NOT MADE TO OVER HEAT. THIS GREATLY INCREASES THE CHANCE OF A FIRE. BMW KNOWS THEY HAVE A PROBLEM BUT IS NOT RECALLING THE WATER PUMPS UNTIL 2006-2011. I THINK THE 1ST GENERATION MINIS SHOULD HAVE THE SAME RECALL AS MOST MINIS INCLUDING MINE HAS/HAD A WATER PUMP ISSUE AND WOULD LIKE OVER A THOUSAND DOLLARS TO HAVE IT REPLACED. I HAVE CAUGHT MINE EARLY BUT ONLY BECAUSE I JACK UP MY MINI TO CLEAN THE UNDERBODY ABOUT ONCE A MONTH. MINI COOPERS ARE WELL KNOWN FOR THEIR WATER PUMPS, THERMOSTATS, AND POWER STEERING, FAILING. I AM 18 YEARS OLD AND WOULD LIKE TO USE THIS CAR TO TRAVEL FROM SOUTH CAROLINA TO WISCONSIN IN THE FUTURE, YET IF MY COOLANT SYSTEM (WATER PUMP OR THERMOSTAT) COULD GO OUT AGAIN AT ANY TIME AND COST A FORTUNE TO REPLACE AND LEAVE ME STRANDED ON THE SIDE OF A HIGHWAY. I WILL BE TAKING A PLANE EVERY TIME I TRAVEL A FEW HUNDRED MILES AND RENT A CAR. THIS MUST BE ADDRESSED! I JUST PAID 1200 FOR MINI TO REPLACE A WATER PUMP THAT SHOULD HAVE HAD AT THE LEAST 30-50 THOUSAND MILES MORE. *TR

THE PASSENGER SIDE AIRBAGS REMAIN ON WITH OR WITHOUT SOMEONE IN THE SEAT. CAUSES CONCERN IF AIRBAGS WILL OPERATE IN A CRASH. *TR