SUZUKI Complaints

MOTORCYCLE STARTED TO VIBRATE MORE AT HANDLE BARS AND BECAME UNCOMFORTABLE TO RIDE. ELECTRICAL OUTPUT FROM THE MAGNETO WAS ALSO STARTING TO DROP IN DC OUTPUT. SELF INVESTIGATION INTO ISSUE REVEALED THAT THE INTERNAL MAGNETO ROTOR THAT NORMALLY HAS 6 MAGNETS EPOXIED TO IT, NOW ONLY HAD 4 EPOXIED IN THE CORRECT PLACE. THE OTHER 2 HAD BROKEN THE BOND AND WERE SLIDING AROUND CAUSING DAMAGE AND WERE ALL BUNCHED UP CAUSING THE VIBRATION ISSUE ALONG WITH THE LOW VOLTAGE OUTPUT TO THE ELECTRICAL SYSTEM. ENGINE WAS CLEANED OUT, AND PART REPLACED WITH NEW SUZUKI OEM PART. *TR

THIS IS A SECOND FAILURE. MOTORCYCLE STARTED TO VIBRATE MORE AT HANDLE BARS AND BECAME UNCOMFORTABLE TO RIDE. ELECTRICAL OUTPUT FROM THE MAGNETO WAS ALSO STARTING TO DROP IN DC OUTPUT. SELF INVESTIGATION INTO ISSUE REVEALED THAT THE INTERNAL MAGNETO ROTOR THAT NORMALLY HAS 6 MAGNETS EPOXIED TO IT, NOW ONLY HAD 3 EPOXIED IN THE CORRECT PLACE. THE OTHER 3 HAD BROKEN THE BOND AND WERE SLIDING AROUND CAUSING DAMAGE AND WERE ALL BUNCHED UP CAUSING THE VIBRATION ISSUE ALONG WITH THE LOW VOLTAGE OUTPUT TO THE ELECTRICAL SYSTEM. ENGINE WAS CLEANED OUT, AND PART REPLACED WITH NEW SUZUKI OEM PART. THIS IS THE SECOND FAILURE IN THE SAME BIKE OF AN OEM SUZUKI PART. FIRST FAILURE ODI 10594978. *TR

MOTORCYCLE STARTED TO VIBRATE MORE AT HANDLE BARS AND BECAME UNCOMFORTABLE TO RIDE. ELECTRICAL OUTPUT FROM THE MAGNETO WAS ALSO STARTING TO DROP IN DC OUTPUT. SELF INVESTIGATION INTO ISSUE REVEALED THAT THE INTERNAL MAGNETO ROTOR THAT NORMALLY HAS 6 MAGNETS EPOXIED TO IT, NOW ONLY HAD 1 EPOXIED IN THE CORRECT PLACE. THE OTHER 5 HAD BROKEN THE BOND AND WERE SLIDING AROUND CAUSING DAMAGE AND WERE ALL BUNCHED UP CAUSING THE VIBRATION ISSUE ALONG WITH THE LOW VOLTAGE OUTPUT TO THE ELECTRICAL SYSTEM. ENGINE WAS CLEANED OUT, AND PART REPLACED WITH NEW SUZUKI OEM PART. *TR

OCS SENSOR MAT INSTALLED IN THE FRONT PASSENGER SEAT MAY FAIL DUE TO REPEATED FLEXING OF THE MAT FROM USE OF THE SEAT. AS A RESULT, DURING A CRASH NECESSITATING DEPLOYMENT, THE AIR BAG WILL DEPLOY REGARDLESS OF WHETHER THE FRONT SEAT OCCUPANT IS AN ADULT OR A CHILD. * WILL NOT DETECT PASSENGER IN SEAT AT WEIGHTS OF 150 LBS OR BELOW. *TR

HUSBAND WAS DRIVING VEHICLE WHEN THE FRONT TIRE GAVE WAY AND BENT IN FROM FRAME. TOOK TO THE REPAIR SHOP AND WAS INFORMED THAT THE ENTIRE FRAME WAS ROTTED OUT. THE VEHICLE COULD NOT BE REPAIRED AS THE PART IS NOT AVAILABLE. THE CAR ONLY HAD 129,000 MILES ON IT. THIS IS A COMMON PROBLEM WITH THE CAR AND IT SHOULD HAVE BEEN RECALLED. FORTUNATELY, NO ACCIDENT OCCURRED AND NO INJURIES WERE SUSTAINED. SHAME ON SUZUKI FOR PRODUCING INFERIOR CARS. THIS IS A SERIOUS SAFELY ISSUE! *TR

TL* THE CONTACT OWNS A 2007 SUZUKI SX4. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 10V513000 (VISIBILITY) AND NHTSA CAMPAIGN NUMBER: 13V405000 (AIR BAGS) HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIRS. THE DEALER STATED THE PARTS WERE NOT AVAILABLE FOR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT DID NOT EXPERIENCE ANY FAILURE. UPDATED 8/12/14*CN UPDATED 09/5/2014 *JS

TL* THE CONTACT OWNS A 2008 SUZUKI SX4. THE CONTACT STATED THAT THE AIR BAG SENSOR ILLUMINATED INTERMITTENTLY. THE CONTACT MENTIONED THAT A PASSENGER WAS SEATED IN THE PASSENGER SEAT BUT THE WARNING LAMP STILL INDICATED THAT THE AIR BAG WAS OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN EXPLAINED THAT THE PARTS WERE NOT AVAILABLE IN ORDER TO DO REPAIRS FOR RECALL NHTSA CAMPAIGN ID NUMBER: 13V405000 (AIR BAGS) AND WAS NOT ABLE TO PROVIDE A SPECIFIC DATE WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT ABLE TO BE REACHED AFTER NUMEROUS ATTEMPTS. THE VEHICLE FAILURE AND CURRENT MILEAGE WAS 36,000.

I WAS DRIVING DOWN A BUSY STREET IN STOP AND GO TRAFFIC. WHILE STOPPED AT A STOP LIGHT, MY VEHICLE MADE A VERY LOUD "CLUNK" NOISE, LURCHED FORWARD AND THE CHECK ENGINE LIGHT CAME ON. WHEN I ATTEMPTED TO ACCELERATE AFTER THE LIGHT TURNED GREEN, I HAD TO PUSH THE GAS PEDAL ALMOST TO THE FLOOR TO GET THE VEHICLE TO MOVE FORWARD. I PULLED OVER AND PARKED, TURNED THE VEHICLE OFF, WAITED ABOUT A MINUTE, TURNED THE VEHICLE BACK ON, AND THE PROBLEM HAD GONE AWAY ALTHOUGH THE CHECK ENGINE LIGHT WAS STILL ON. A DAY OR SO LATER, WHILE I WAS DRIVING ON THE HIGHWAY GOING APPROXIMATELY 65 MILES PER HOUR, THE VEHICLE MADE THE "CLUNK" NOISE, LURCHED FORWARD AND THE CHECK ENGINE LIGHT CAME ON AGAIN. THIS TIME, BECAUSE I WAS ALREADY IN MOTION, THE RPMS JUMPED UP ABOVE 3000, WHICH IS VERY HIGH FOR A 4 CYLINDER ENGINE ONLY GOING 65 MILES PER HOUR. AGAIN, I PULLED OVER, TURNED THE VEHICLE OFF, WAITED ABOUT A MINUTE, TURNED THE CAR ON AND WAS ABLE TO DRIVE THE VEHICLE NORMALLY AGAIN ALTHOUGH THE CHECK ENGINE LIGHT REMAINED ILLUMINATED. THIS ISSUE HAS BEEN HAPPENING RANDOMLY ABOUT 20 TIMES A YEAR OVER THE COURSE OF THE LAST 2 1/2 - 3 YEARS. *TR

I STARTED THE CAR. LET IT IDLE FOR A MINUTE TO BRING THE RPM DOWN. I TRIED TO SHIFT IT TO REVERSE BUT IT WOULD NOT GO. IT HAD AN ENGINE WARNING LIGHT ON. I SHIFTED BACK TO PARK AND TURNED THE CAR OFF. I LET IT SET FOR A MINUTE THEN RESTARTED IT. WHEN I SHIFTED AGAIN, IT CLUNKED AND WOULD BARELY MOVE. I SHIFTED TO DRIVE AND IT CLUNKED AND WOULD BARELY MOVE. I AM A SINGLE 55 YEAR OLD WOMAN. I WORK 2 JOBS AND LIVE 8 MILES OUT OF TOWN. I CAN'T AFFORD TO HAVE THIS CAR DOWN. I BOUGHT IT BECAUSE OF THE LOW MILEAGE. IT ONLY HAS 39,000 MILES. *TR

I HAVE REPLACED THE TRANSMISSION RANGE SENSOR TWICE SINCE PURCHASING MY CAR NEW IN 2008 AND JUST LAST WEEK I STARTED HAVING THE SAME ISSUE! SO I WILL BE REPLACING THIS SAME PART FOR THE 3RD TIME SINCE PURCHASINGIT NEW 6 YEARS AGO. *TR