VOLVO Complaints

The high voltage coolant heater failed. It will not heat when running solely on battery. Defrost therefore will not get warm to clear windshield

The infotainment will randomly overheat and a system warning will come on that begins cooling the cluster by turning on the air vents. I have taken the vehicle to Volvo several times to address the issue and they do a software update but the problem returns within a few weeks. The safety sensors will also randomly turn off while driving. I have contacted Volvo several times to no avail. My local dealer has chosen to stop seeing my vehicle and now I have a malfunctioning car and now having to find another dealer will result in lost work time.

2ND row, center seat, seatbelt lock will not work, will not latch/lock, cannot use seatbelt. Since owning car, the seatbelt locked intermittently, as of today, it does not work at all.

The contact owns a 2019 Volvo XC40. The contact stated while at a stop sign or a stop light, the engine revved loudly, and the vehicle suddenly lunged forward out of control. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 7,600.

In the middle of a cold snowstorm the screen froze and started glitching. As I was trying to change the drive mode to all wheel drive the ESC off button triggered and ESC stayed off without AWD mode and screen was unresponsive. Had to pull over and turn car off and back on for screen to reset.

Tire size: 255/40 R21 The original equipment Pirelli Scorpion Zero All Season VOL PNCS tires (255/40 R21 102V, DOT JXB RW582P) on my 2024 Volvo XC60 CPO developed significant tread chunking and active delamination, discovered at approximately 19,225 miles — less than 40% of the expected tire lifespan. Component: Both front tires are available for inspection upon request. Safety risk: Tread chunks are physically separating from the tire at the tread edge. Active delamination at highway speeds presents a serious blowout risk to myself, passengers, and other drivers. Prior symptoms: No warning lamps illuminated. Initial delamination was noticed earlier by a family member but was not fully examined at that time. Upon closer inspection at 19,225 miles, the extent of the tread chunking and delamination on both front tires was confirmed. The condition appears to have been progressive. Additional note: These tires are original equipment and have never been replaced. The vehicle has been driven exclusively on paved roads under normal conditions with no impacts, curb strikes, or overloading. This is consistent with a known manufacturing defect affecting Pirelli Scorpion Zero tires produced in 2021–2022 installed as OEM equipment on Volvo XC60 vehicles.

The contact owns a 2026 Volvo VNL4. The contact stated that the front lift axle lowered unintendedly while in the travel position. The computer sensed the abnormal weight while driving in high winds. While driving in snow, rain, and wind, the contact was concerned about a crash while driving the vehicle. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired after several months. The manufacturer was contacted. The failure mileage was approximately 1,800.

Car was parked at my house. After a heavy heavy rain, I saw 1/2" standing water on the passenger side floorboards. The cowl drainage had been blocked, and I was told water had found it's way into the cabin. It's an EV, so this is a serious issue. My climate control was inoperative, the tire pressure sensors also affected. And not sure what other systems may have been damaged. This had never happened before, and my repair estimate is $5,000.00. It is unfathomable that a car of this level (and price) could have a design that would allow this situation. Thank you for your attention.

On February 17, 2026 I was driving from Sacramento, CA to Oakland, CA (approximately 100 miles). At the start of the trip, I discovered that the vehicle’s heating and climate control system was not functioning. Specifically, the heater would not turn on, and as a result, the windshield defrost system would not activate. I attempted multiple times to turn the vehicle off and restart it to see if the system would reset, but the problem persisted. I also tried manually activating the front defrost using the dashboard controls; however, the defrost function would not engage. Weather conditions were approximately 40°F with heavy rain. Because the defrost system was inoperable, the windshield and windows became fogged over during the drive. This significantly impaired my visibility. I was unable to adequately clear the windshield, creating a dangerous driving condition for the duration of the trip. This malfunction directly impacted my ability to safely operate the vehicle in cold and rainy conditions. The inability to use the defrost system created a serious safety hazard due to reduced visibility.

The contact owned a 2019 Volvo XC90. The contact stated that while driving approximately 50-52 MPH, there smoke coming from the front passenger’s side wheel well of the vehicle. The contact stated that an off-duty Police Officer witnessed the failure and activated the Emergency Lights, allowing the contact to safely pull off the highway The contact immediately pulled over and stopped the vehicle. The grandson seated in the front passenger’s seat immediately exited the vehicle and the contact was able to unbuckle and removed the [XXX] from the second-row middle seat. The contact stated that moments later there were explosions, and there was black smoke and flames engulfing the vehicle. The vehicle was destroyed. There were no injuries sustained; however, all three occupants of the vehicle experienced emotional trauma from the vehicle catching on fire. Medical attention was not needed. A Police Report was filed at the scene and the vehicle was towed away. The contact stated that the car seat in the rear of the vehicle was destroyed. The vehicle was examined by an Insurance Adjuster, and it was determined that the fire had started in the engine compartment. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 61,511. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)