VOLVO Complaints

My 2018 Volvo XC90 had repeated water leakage from the panoramic sunroof. In most cases, when the vehicle is parked flat or the front is at a slight angle, water leaks in and collects in the cargo area. It collects into a plastic compartment over the battery located on the right side of the cargo area and/or on top of the rear cargo mat. When the vehicle is moving and it is raining, water leaks in from the rearview mirror, making the entire dash, screen, shifter and both driver and passenger wet. The rain also comes in from the rear right side of the second row making the entire seat or any passenger sitting there wet. Volvo is not acknowledging this defect nor are there any solutions in place. This is extremely concerning.

The passenger side rear door locked and could not be open from either the inside or the outside. The dealer concluded that the door lock failed in the locked position. It gained entry to the door panel with the door shut, removed the old lock, opened the door, installed a new lock assembly and reassembled the door. Because the car was slightly out of warranty, we had to pay for the repair. Until this was done, we felt very unsafe. In the event of an accident or emergency, the passenger on that side of the car would not be able to exit the car. There was no warning prior to this happening. It just stopped working.

Faulty seal in OEM windshield sealant/silicone causing water to leak on the inside of car, headliner, and inner windshield. Can cause visibility issues and mildew.

RVXX2409 - Bendix ABS ECU Recall C6619 RVXX2004 Pedal Carrier Date Code Inspection Recall

The contact owns a 2020 Volvo VN. The contact received notification of NHTSA Campaign Number: 24V790000 (Electrical System, Service Brakes, Hydraulic); however, the contact called the local dealer to schedule an appointment and was informed that there was no recall associated with the VIN. The manufacturer was contacted and informed the contact that there was no recall associated with the VIN. The contact had not experienced a failure. Parts distribution disconnect.

Driving as normal through a major intersection and the car began to jerk and stutter when trying to accelerate. there was no warning or symptom prior to this issue, but upon it happening, the turtle warning light appeared and had the display had an engine system message saying "reduced performance". I was able to pull over. Then turned the car off and back on, which then allowed me to pull in to the nearest parking lot. The warning light remained on. The car was towed to the nearest Volvo dealership. They confirmed the issue was a failure of the fuel pump. They replaced the fuel pump. Luckily I had passed the intersection and the cars around me were still accelerating from a lower speed, so this did not cause an accident.

The evaporator core malfunctioned (AC system), resulting in the failure of the air conditioning system. The defective part remains installed in the vehicle and is available for inspection upon request. This issue compromised the vehicle's ability to maintain a comfortable and safe environment, particularly in extreme weather conditions where the lack of a functioning air conditioning system can pose health risks, especially to young children or elderly passengers. The problem has been confirmed by an authorized Volvo service center, where the leak was identified during an inspection. Prior to the failure, there were no warning lamps or error messages. However, the air conditioning began to perform inconsistently several weeks prior to the complete failure. Given the timing of this issue, just beyond the warranty period, and the evidence suggesting this may be a recurring problem in certain XC90 models, and Volvo Customer Care denied any assistance or support in this matter.

I have a 2016 XC90 T6 Inscription. The issue started after refill the engine oil and led to malfunction in engine system. The engine list the power and slowed down the car while driving. I brought the car to the dealer 2 times already and had been fine for 3 months. However, the engine oil light showed up to refill after 3 months. I am aware that other Volvo owners are facing the same issue and it is due to defect of piston and piston ring.

I went through a car wash and then pulled into the first parking spot near the vacuum cleaners. As I was braking and coming to a stop, the car suddenly lurched forward and accelerated on its own. Despite pressing the brake pedal multiple times, the car did not stop until it went about 15ft. To avoid hitting the building wall directly in front of me, I swerved to the left. The car collided with the metal pole supporting the vacuum cleaner structure, causing significant damage to the entire side of the vehicle, and also clipped the corner of the building on the right as it went through the area. There were no warning lights, messages, or other indications of an issue before the incident. I have videos of the incident from the car wash. -The issue involves unintended acceleration, potentially related to the accelerator pedal sensor (APS), throttle control system, or braking system. It may also be electrical, as similar issues in 2021 and 2022 Volvo XC40 Recharge vehicles were reported due to water damage and corrosion in the cable harness, leading to unintended APS signals. The vehicle is available for inspection upon request. -The vehicle suddenly accelerated without input causing a collision. To avoid hitting a building wall in front of me, I swerved to the left, and the car struck the metal pole supporting the vacuum cleaner structure. The impact caused significant damage to the side of the car and clipped the corner of the building as well. This incident could have resulted in severe injury or damage had anyone been nearby or if the car had collided directly with the building (which held the car wash electrical panel). As it stands I have a stiff neck and some PTSD. -No, the problem has not yet been reproduced or confirmed by a dealer or service center. It's at the collision center. -No, the vehicle has not yet been inspected by the manufacturer, police, insurance, etc. -No warning lamps, messages, or other symptoms appeared before/during/after the incident.

Vin: [XXX] We just had the starter go bad at roughly 66000 miles. When the repair shop had removed the bad starter they noticed a very odd failure. The nut/stud on the starter was stripped. They stated that this was definitely from a manufacturing defect. I can provide the bad starter and receipt of the cost of replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)