CHEVROLET Complaints

I own a 2015 Chevrolet Silverado 3500HD Duramax diesel. At approximately 130,000 miles, the high-pressure CP4 fuel pump failed internally, sending metal shavings throughout the fuel system and contaminating major components. The truck suddenly lost power on the freeway and became inoperable without warning. I was barely able to get out of traffic before it had to be towed to a Chevrolet dealership. This created a serious safety hazard, especially considering the risk if it had happened while towing my fifth wheel with my family. A failure like this should not happen at this mileage on a heavy-duty diesel truck. I also cannot afford the extremely high cost of repairing the entire fuel system. From my research, many other owners have experienced the same CP4 fuel pump failure, which often destroys the entire fuel system and leads to very expensive repairs. I believe this is a widespread defect, not normal wear and tear. I ask NHTSA to review these failures and take action to protect vehicle owners from similar dangerous and costly failures. This truck currently sits at the dealership as I cannot afford the repairs and GM will not fix what they know is faulty parts.

I had a complete loss of steering and had to have the truck towed to the dealership. This could have caused a very serious accident. There was no previous warning - it just went out. The dealership charged me $2183 to replace the steering gear. According to the literature, the steering function should last to well past 100K miles (my truck had 66,552 miles on it). In addition, there are multiple reports of steering going out online - perhaps a recall is in order. The literature also states that if diagnostic code C1599 then the steering rack is completely fine mechanically but it has simply lost its electrical connection. That is the code that the dealership saw - it sounds like the fix could have been much simpler and cheaper.

On June 22, 2026, my Chevy Silverado was inoperable and had to be towed to the Chevy dealership. After a period of examination by the service staff, it was deemed to have experienced CATASTROPHIC ENGINE FAILURE. My truck has the 6.2L engine, but was NOT included in the original recall. It had just been serviced on 6/19/2026 and was only driven approx. 20 miles to my home. I have a video of what it was doing when I went to leave for work two days later on 6/22 when it wouldn't run without major issues and a burning smell.

What component failed: The “regen on demand” switch broke while using it. Safety: This incident put me, the occupants of my vehicle (my children), and the vehicles around me at risk. Reproduction: There was no need. It is exceptional obvious that the switch is broken and has failed. Inspection: The truck and broken switch were observed by the dealership that services the truck. Warnings: There were no precursors to the failure. Narrative: On Thursday, 7/16/26, I was driving my 2026 Chevrolet Silverado EV. I normally drive in “single pedal drive” mode which provides energy recovery in lieu of mechanical braking. Additionally, I use the “on demand regeneration” for additional slowing and energy recovery. On demand regeneration is somewhere between single pedal drive and mechanical brakes. During this drive I was coming up to stopped traffic and slowing using the regen on demand switch. The switch snapped / broke and the additional slowing / energy recovery stopped instantly. I had to immediately apply the brakes in order to remain a safe distance from the vehicles in front of me. While I am able to safely operate the vehicle without this function, the manner in which the failure occurred is concerning and should be investigated. I am happy to speak with anyone who needs more information.

The high pressure fuel pump seized, shattering the camshaft, dropping metal fragments into the cylinders causing total engine failure. GM issued a safety recall for certain 2021-2022 Chevy equinox due to a defective fuel pump modules but it was not accurate. GM is currently facing major class action lawsuits alleging that their equinox fuel pumps are fundamentally defective. The lawsuits highlight that the component fails, causing catastrophic damage and GMs initial recall fixes were inadequate.

Transmission started shuttering on way to work went out before making it home. No problem before this trip.

This has happened 5 times since purchasing this 2026 Chevy Equinox RS. While driving, all of a sudden, without any notice, the dashboard lights up with warnings about "BRAKES"...Not exactly sure what is said because it doesn't stay on the screen very long. Next it says, STEERING ASSIST IS REDUCED..DRIVE WITH CARE....and a small area under, "Mileage till empty" says....BRAKE...in red, while still being in DRIVE. When pressing on the brakes to slow down to pull over, there ARE NO BRAKES.!!! The brake pedal goes to the floor and Equinox very slowly comes to a stop, so I can pull off the road and stop. Now if I turn off the engine, turn it back on, it seems to reset itself and I start driving again, not knowing when I might die because of the brakes going out again when someone pulls out in front of me. HOW CAN A VEHICLE THAT SPORADICALLY LOSES THE BRAKES, BE ALLOWED TO BE SOLD ON THE MARKET ??? This vehicle now has 13,147 miles on it and had very few when it first happened. We are now at 5 times, not knowing if the 6th time there will be death for my family to deal with. My dealer said they would let us know as soon as they learn about this issue, as they know nothing the 1st time..Several cases have been reported and our dealer failed to notify us about anything...Do I drive the Equinox until someone is killed or do I demand my dealership to furnish me a SAFE Equinox to drive until they fix mine. ? It's obvious that I will eventually be injured or killed in this Chevy Equinox caused by General Motors' incompetence..I am going to demand my dealer to furnish me with an equivalent vehicle.

was stopped at a red light. When the traffic light turned green, I pressed the accelerator to proceed through the intersection, but my vehicle did not respond or accelerate immediately. After several seconds, the vehicle finally began to move. This unexpected delay created a safety concern because I was unable to accelerate when traffic began moving.Which caused built up traffic and an almost wreck behind me

The left front turn signal becomes inoperable at times. The foreword collision indicator warning will come on unprovoked at times. Both conditions correct when you cycle the ignition switch. I consider the turn signal problem a safety issue because it happens with no warning and oncoming traffic may not know I am turning left or changing lanes. When the foreword indicator appears, I doubt the system is operable.

A.The engine is stalling while driving. This has happened four different times. Three times while towing, and one time while backing up a small hill. This is a scary situation because three of the four times almost caused an accident. 1.We were driving to Texas, pulling a pontoon boat. While exiting the highway, we were entering into an intersection at a speed of about 10 miles per hour, and the truck shut down. The truck said, “Start the motor and place it into gear.” Or something similar to that. 2.We were in stop-and-go traffic on the highway, and the truck shut down. Once again, I had to restart the motor and shift into gear. 3.We were entering a parking lot from the main road, and the truck shut down. Again, I had to restart the motor and shift into gear. 4.The three times above are during a time when we were towing. The fourth time is when we were backing up a small hill. The rear tires lost traction and spun for a second or two, and then the truck shut down and started to roll forward. Once again, I had to restart the motor and place it into gear.