CHEVROLET Complaints

There was a fire in the trunk on the way to work. Fire department was called to inspect the car and make sure that the fire was out. Fire melted fuse box located in the trunk along with wiring harness and wires, also causing all electrical items to stop working. Claim was attempted to be made, but insurance did not cover this particular issue. After hours of reading as well as watching videos, this seems to be an on problem for Malibu's from 2011-2016. I bought this car one year ago and had a mechanic inspect the vehicle.

The contact owns a 2023 Chevrolet Malibu. The contact received notification of NHTSA Campaign Number: 26V212000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

My 2023 Chevrolet Silverado 1500 experiences an intermittant, uncommanded mechanical drivetrain lockup and severe binding when accelerating from a complete stop. The vehicle rolls fine in a straight line for several feet, but the exact moment the steering wheel is turned slightly (a couple degrees), the drivetrain violently binds up. This creates resistance in the steering and acceleration, as well as a severe physical and audible metallic clunking slam and massive shockwave vibrations felt directly through the steering wheel, floorboards, brake/gas pedals, and driver’s seat. During the last event, the vehicle threw a "Service 4 Wheel Drive" dash message and refused to shift out of "Auto" mode back into 2WD. Because this is a pure mechanical interference/binding issue, it does not consistently throw active electronic trouble codes. A standard OBD2 code scan will show nothing. After turning the vehicle off for several hours and testing again, the problem persisted. After towing the vehicle to a dealership (6/10/2026) it sat for at least 5 days before dealership service looked at it. By this time, the active warning lights cleared. My initial servicing dealership refused to perform physical hardware or fluid diagnostics under my factory warranty, stating they would not look at the vehicle unless I paid $860 out-of-pocket or until the drivetrain "completely grenaded" on the road. Because this uncommanded lockup restricts my ability to steer the vehicle safely from a stop, it presents an immediate crash hazard. At the direction of General Motors Corporate, I am escalating this issue and moving the vehicle to a secondary certified facility (Feldman Chevrolet of Novi) on June 23, 2026, for a formal physical hardware and fluid tear-down inspection.

Telematic module diagnosed to fail by the dealer service department. Replacement part is not available after 3 months, and not ETA from GM parts department.

I am having the same issue as the GM Safety Recall N232426400 - where it says it is a common issue in 2020-2024 Chevy 1500's (which my truck is a 2022 Chevy). Where the tailgate will drop by itself. I looked into this recall and my truck is not included. However, it just rained heavy and now my truck's tailgate is dropping on it's own. This is a safety risk due to loading the truck bed and having it open on its own without me knowing resulting in items falling out of my truck onto the roadway. Another thing is my lane keeping assist is no longer working.

6/12/26 ( 2023 Chevy Silverado - 6.2 liter engine) While driving at approximately 40 MPH on a two lane road, the truck shut off. After multiple attempts, the engine failed to restart. The transmission locked up in park and would not release. This required the truck to be dragged up on the flat bed wrecker instead of rolling freely. Prior to this instance there have been several issues with the electrical system. 1. radio sound shuts off. does not come back on. 2. Head lights stay on for 10 minutes after vehicle is turn off. 3. Tail gate opens on it own. Tail gate doesn't open with fob. 4. door locks fail to operate correctly. 5. When drivers door is opened a beeping sound starts and doesn't stop until door is closed. I have reported these problems to GM & have two case numbers. The dealership reports that the 6.2 replacement engines have had multiple failures.

Walked out of the car into the gas station came back out the brake pedal was locked up literally didn’t even wiggle at all couldn’t start the car I tapped it a couple times and then it made a horrible snap/pop sound and works fine for now

The contact owned a 2018 Chevrolet Camaro. The contact stated that while driving at an undisclosed speed, the vehicle lost steering functionality, preventing the contact from steering from side to side. Additionally, the message "Service Power Steering Assist" was displayed. The contact referenced NHTSA Campaign Number: 25V175000 (Steering); however, the VIN was not included in the recall. The vehicle was taken to the dealer, where it was diagnosed with power steering failure. The vehicle was repaired out of pocket. The manufacturer was notified of the failure. The failure mileage was 14,000.

Brake vacuum, pump failed while driving which made the brakes not work. I had it towed to a dealer and they found that the pump was internally damaged. Pump was then replaced. There was no warning this was about to happen and it happened suddenly. One moment the car had brakes and the next there was no braking. A very dangerous situation and we were lucky to not have a major accident.

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, there was a message related to brakes. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and there was an abnormal grinding sound coming from the brakes. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The dealer informed the contact that the brake sensors had detached. The repair was not covered under warranty. The manufacturer was contacted and confirmed that the repair was not covered under warranty. The failure mileage was approximately 35,000.