CHEVROLET Complaints

The contact owns a 2025 Chevrolet Blazer. The contact stated that after the vehicle was repaired under NHTSA Campaign Number: 25V433000 (PARKING BRAKE), while driving approximately 45 MPH, the Forward Collision Avoidance system erroneously activated, causing the vehicle to abruptly stop in the middle of the road. During the failure, the message "Front Brake Applied" was displayed. The contact stated that approximately 10-minutes prior to the failure, the message that the Forward Collision Avoidance sensors were disabled. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not contacted. The failure mileage was 18,000.

While driving at highway speeds, multiple warning lights illuminated on the dashboard at the same time, including engine and powertrain warnings. The vehicle suddenly began operating abnormally, with loss of power and unstable driving behavior, making it unsafe to continue driving. This same issue has occurred multiple times previously and the vehicle has been taken to an authorized Chevrolet dealership for repairs on three separate occasions. Each time, repairs were performed, but the problem returned. The most recent incident occurred while driving on the highway and created a serious safety risk to the driver and other vehicles. The vehicle is not safe to drive.

I remote started my car using the factory installed remote starter, and approximately 5 minutes later I heard my car alarm start going off, so I went to investigate and when I opened the drivers side door, my car was filled with smoke and flames were coming up from the front passenger footwell, underneath the dash where the HVAC blower motor is located. I closed the drivers door and rushed inside to grab a fire extinguisher, but within those 10 seconds I was away, the fire has more than tripled in size. So when I opened the passenger door to use the extinguisher, the fire had grown out of control. With the fire put out, I started looking around and noticed that the engine bay for the car still has rubber hoses and pieces of plastic that are fully intact and haven't been burned, yet the interior of the car is completely gone. I have reason to believe the blower motor was the source of the fire. After talking to a few others that own the same car as me, some have said they've been noticing a burning smell and minor traces of smoke coming from that same area

The contact owns a 2021 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the check engine warning light was illuminated, and the vehicle was idling roughly. The vehicle was taken to a certified mechanic who replaced an undisclosed sensor. The contact stated that the warning light remained illuminated. The vehicle was taken to the dealer, who diagnosed that the camshaft had failed and there were metal shavings found in the oil filter; however, the dealer was unable to determine the cause of the failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 119,000.

URGENT Complaint: NO RESPONSE to Demand for Rescission - Odometer Fraud, Deceptive Practices - Banner Ford of Monroe, LA

Back in 7/2025, I was going to a Dr appt in Chandler, Az. When I arrived in Maricopa, Az, my truck stalled at the first stop light and would not start. I went over Kraegan Auto parts and bought a battery. After about 10 days, I was having to jump start my truck for the next few days. I took the battery back and they realized that it wasn’t the battery my truck called for. So, now I have the correct battery and everything working like it supposed to. In Nov 2025, my battery was starting to drain like overnight, and jump starting my truck every morning. I also told them, that the transmission was acting up. When I got on the highway my truck would be at 5000 rpm while doing 60 mph. I be would have to pull over to side of the highway, shut the engine down, and restart. Usually it would be good after the first time. So, up until now, I have no heater, no AC, my windows don’t go up or down, cruise control don’t work, l can’t move my power seat, so my wife has to put a pillow behind her and a pillow beneath her when she drives our truck. And I be still haven’t mentioned all be the little icons that are lit on the steering column. My truck is at the Jerry Seiner Casa Grande, Az. I have the protection plus coverage on my truck with GA Security, and I was told that because it’s a battery issue and found me at fault, they won’t cover me and I need to pick up my truck, because I can’t afford a $680.00 price tag. I’m on Medicare. That’s why I paid the $3500 for the protection plus coverage. So I guess it’s my fault or fault of my battery, my transmission doesn’t shift gears, power windows don’t work, heater or AC don’t work, can’t forget the cruise control. They said they are not covering nothing, to come get my truck.

A car approached my blind spot and the blind spot detection did not alert. I tried to change lanes assuming the system was functioning and nearly ran someone off the road. Shortly after this the “service blind spot detection light” came on. Following this failure the vehicle telematics went out rendering the paid on star safety system useless. Parts to remedy the issue on indefinite back order per GM on 12/8/25.

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that while starting the vehicle, there was a loud rattling sound coming from the engine compartment, with the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the vehicle jerked unexpectedly, with the check engine warning light illuminated. Additionally, the contact stated that while driving at an undisclosed speed, the brake pedal became inoperable. The contact reported that the brake pedal was depressed and traveled to the floorboard, and the ABS system vibrated following the brake pedal failure. No warning lights were illuminated for the brake failure. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 139,000.

On Sunday Nov. 16th, my steering wheel felt like it was "slipping", akin to how it feels when your serpentine belt tensioner is failing. I checked it out while wife turned the wheel, didn't see any problem, and we went on our way. Later in the day as we were leaving a parking lot, the problem occurred again but worse. And we got a warning about trailer brake controller needs repair. After reviewing similar problems on Reddit, I found it was still safe to drive, so we drove home without further incident. Monday I decided to take it to O'Reilly auto parts and have a code scan done. Except, as soon as I turned out of the driveway, my wheel completely froze up solid. I could NOT move the wheel (q2)! Since the wheel was still turned, I backed it into the driveway and we took our car to buy our own code scanner. It showed more than just one fault code for the brakes, there were 5. I called Fox Chevrolet to schedule al appointment for the next day. Fortunately, the failure occurred as the Advisor attempted to turn the wheel (q3). Long story short: problem was a rusted/rotted out ground wire (q1)! Behind the front driver side tire, encased in a boot. Tech told the Advisor he'd never seen that one before. $40 part, and $400 to install it (q4). I was happy it wasn't a power steering rack failure (electric) but the more I thought about it, felt I needed to report this. You needed a dealer scanner to catch this and trace it to a ground fault. Probably better for you to contact dealer Advisor and Tech to get a better breakdown on this (q1). Dealer was great, they could have sold me an $1800 steering rack and I'd have never known. Could this failure have happened to someone driving on the street and this pop up all of a sudden (q2)? I believe so. Glad I didn't find out firsthand. The problem went away overnight twice, and then all of a sudden your wheel is LOCKED. I'm curious as to if others are or have faced this, thus my submittal. Thanks for your time.

I had just received my truck back from a complete engine replacement from the dealer and had driven it 10 miles back to my house and the check engine light came on and the dash said reduced power service DPF system. The truck was towed to dealer for PO302 code and injector #3 was replaced.