MINI Complaints

NORMAL DRIVING CONDITIONS. 2004 MINI COOPER POWER STEERING FAILED. NO LEAKING FLUIDS, NO WARNING LIGHTS OR ABNORMAL SOUNDS TO HINT THAT THIS WAS AN IMPENDING ISSUE. CAR WAS VERY DIFFICULT TO MANEUVER. WE ARE CONCERNED THAT THIS IS A SAFETY ISSUE IN PARKING LOTS, WITH PEDESTRIANS OR AT SPEED AROUND OTHER VEHICLES. *TR

THE CHECK ENGINE LIGHT HAS COME ON AT 55K MILES AND I HAVE BROUGHT THE VEHICLE IN TO GET CHECKED AT THE DEALER. THE SERVICE DEPARTMENT REPORTS THAT THE TIMING CHAIN IS BEGINNING TO FAIL AND NEEDS TO BE REPLACED, ALONG WITH A WATER PUMP LEAK. THE TIMING CHAIN IS A KNOWN FAILURE AND STILL HAS NO RECALL. *TR

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT WAS DRIVING 35 MPH WHEN THE POWER STEERING FAILED. THE CONTACT STEERED THE VEHICLE TO A PARKING LOT WHERE HE WAS ABLE TO TURN THE ENGINE OFF. ONCE THE VEHICLE WAS RESTARTED, THE STEERING RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 72,000. UPDATED 01/13/11 *BF UPDATED 01/24/11

FOLLOWING REAR END IMPACT, THERE WAS AN ENGINE COMPARTMENT FIRE, WHICH WAS LATER TRACED TO THE POWER STEERING PUMP. TERMINALS WERE BURNED OFF THE PUMP, AND ALTERNATOR ALSO FAILED AS A RESULT. NOTE: THERE WAS ABSOLUTELY NO COLLISION DAMAGE TO FRONT END. *TR

MY 2004 MINI COOPER S POWER STEERING PUMP JUST FAILED AND HAS TO BE REPLACED AFTER ONLY 45K MILES. *TR UPDATED 08-29/11 *BF

TL*THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT PASSENGER AIR BAG LIGHT ILLUMINATED ALTHOUGH A PASSENGER (WHO WEIGHED OVER 200 LBS) WAS SEATED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE SENSOR MAT NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 48,500 AND THE CURRENT MILEAGE WAS APPROXIMATELY 153,600.

WHILE DRIVING ABOUT 30 MPH, THE POWER STEERING SUDDENLY QUIT WORKING. I ATTEMPTED TO MAKE A RIGHT HAND TURN AND CONTROLLING THE VEHICLE WAS VERY DIFFICULT. THERE WAS NO WARNING THAT THE STEERING WAS ABOUT TO GO.

THE AIRBAG WARNING LIGHT STAYS ON EVEN WHEN THERE ISN'T A PASSENGER IN THE PASSENGER SEAT. THE LIGHT INDICATES THE AIRBAG IS OFF. THE LIGHT ALSO STAYS ON IF THERE IS A PASSENGER IN THE SEAT. I AM NOT SURE IF THE AIRBAG WOULD WORK IN THE EVENT OF AN ACCIDENT. THE DEALER INDICATED I NEEDED A NEW SEAT AT MY COST. TO ME THIS IS A MANUFACTURER'S DEFECT THAT BMW SHOULD FIX. *TR

OVER THE COURSE OF ABOUT A MONTH AND A HALF, THE POWER STEERING BEGAN TO "STICK" IN THAT I COULD NOT STEER RIGHT OR LEFT WITHOUT PHYSICALLY FORCING THE WHEEL TO THE RIGHT OR LEFT, USING ALL MY STRENGTH TO DO IT. I THOUGHT I LOST CONTROL OF THE CAR. THE FIRST TIME, IT WAS A TERRIFYING EVENT. THEN IT WOULD GO BACK TO "NORMAL" THE NEXT DAY, BUT THEN "STICK" AGAIN ON VARIOUS OCCASIONS WITH NO RHYME OR REASON; THERE WAS NO PATTERN AS TO WHEN IT WOULD OCCUR. BUT IT DID HAPPEN AT LEAST ONCE A WEEK. THE STEERING WHEEL WOULD "STICK" NO MATTER IF THE CAR WAS AT A COMPLETE STOP, OR WHILE DRIVING. AFTER CHECKING WITH LOCAL GARAGES, THEY SUGGESTED TO HAVE MY MINI DEALERSHIP REPAIR IT AS NO ONE COULD FIND THE CAUSE OF THE PROBLEM. MINI DIAGNOSED THE FAILED POWER STEERING, AND INSTALLED A FAN WITH PROTECTING "GRI" (PART # 32-41-6-781-742 @ $222.43) AND INSTALLED A REPAIR KIT, LOWER "SECT" (PART # 32-30-6-763-722 @ $186.63). MINI SERVICE FOUND THE STEERING SHAFT KNUCKLE SEIZED UP, MAKING IT HARD TO TURN THE STEERING WHEEL. MINI REPLACED THE STEERING SHAFT, AND ALSO FOUND THE POWER STEERING FAN TO BE SEIZED, SO THEY ALSO REPLACED THE STEERING FAN. INCLUDED IN THIS DIAGNOSIS, MINI FOUND THE CONTROL ARM BRACKETS, WHICH ARE PART OF THE STEERING OF THE CAR, NEEDS REPAIR IN THE NEAR FUTURE TOO. *TR

MY POWER STEERING IN MY 2005 MINI COOPER FAILED WHILE DRIVING. THIS IS A COMMON ISSUE FOR ALL 01-07 MINI COOPERS AND BEFORE SOMEONE DIES OR IS SERIOUSLY INJURED BMW MINI NEEDS TO ISSUE A RECALL AND REPLACE THIS FAULTY PART. I WAS DRIVING HOME FROM WORK AND THE STEERING STARTED TO LOCKUP ON THE HIGHWAY, I THEN PULLED OVER AND TURNED OFF THE CAR THEN RESTARTED AND THE STEERING WORKED JUST FINE. TWO DAYS LATER I WAS PULLING OFF OF THE HIGHWAY AGAIN AND THE STEERING STARTED TO LOCK UP ONCE MORE. I BARELY MADE IT TO A NEARBY PARKING LOT STRONG-ARMING THE CAR WITH EACH TURN. I PULLED INTO A PARKING SPOT AND TURNED OFF THE CAR ONCE AGAIN. AFTER RESTARTING THE CAR THE STEERING STILL WOULD NOT WORK, I EVEN LET IT COOL DOWN FOR A FEW MINUTES TO TRY ONCE MORE. STILL UNABLE TO STEER. HAD TO GET MY CAR TOWED AND HAD TO REPLACE POWER STEERING PUMP AND FAN ON CAR. THIS CAR IS LESS THAN 5 YEARS OLD AND THE POWER STEERING SHOULD LAST THE LIFE OF THE CAR.