SUZUKI Complaints

TL* THE CONTACT OWNS A 2007 SUZUKI BOULEVARD M109R MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, HE PULLED THE CLUTCH LEVER IN ORDER TO DISENGAGE THE MOTOR BUT THE VEHICLE DID NOT RESPOND. THE CONTACT MENTIONED THAT HE WAS UNABLE TO CONTINUE DRIVING SINCE THE CLUTCH HAD BECOME STUCK. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 7,000.

TRANSMISSION RANGE SENSOR IS FAULTY. CAR BANGS INTO GEAR FROM PARK AND REVERSE, AS WELL AS ERRATICALLY SHIFTS INTO NEUTRAL WHILE DRIVING. *JS

2007 SUZUKI M109R TRANSMISSION FAILURE. SECOND GEAR POPS OUT WHEN THE THROTTLE IS ABOUT 4000+ RPM AND SLAMS BACK INTO GEAR. THE RESULT IS A BENT SHIFT FORK AND ROUNDED OFF GEAR ENGAGEMENT TANGS (DOGS). REMOVED THE ENGINE AND TRANSMISSION ON MY OWN, AND REPLACED SUSPECTED PROBLEM PARTS IN THE TRANSMISSION SUCH AS: SHIFT FORKS (TO UPDATED PART NUMBERS), SHIFT FORK SHAFTS (TO SOLID 14MM 4140 STEEL RODS), UNERCUT OR BACKCUT THE GEARS BY 5 DEGREES (TO ALLOW POSITIVE ENGAGEMENT OF THE DOGS WITHOUT SLIPPING APART). THE BACKCUTTING ALONE COULD BE THE SOLE FIX FOR SUZUKI, IF THEY PRODUCED THESE PARTS LIKE THIS (5 DEGREE CUT) FROM THE FACTORY, AND SOLID SHIFT SHAFTS PREVENT WARPAGE TO OCCUR AND THE SHIFT FORKS TO POSITIVELY ENGAGE THE DOGS. ALTHOUGH THE BIKE WAS OUT OF WARRANTY, AND RESEARCH SHOWS THAT SUZUKI IS VERY RELUCTANT TO EVEN ADMIT THIS IS A PROBLEM, IT IS DANGEROUS AND COSTLY FOR THE OWNERS.. *JS

THE RECTIFIER FOR MY 2007 M109R (VZR1800) IS FAILING TO CHARGE MY BATTERY. I REPLACED THE BATTERY, ASSUMING THIS WAS THE REASON THE BATTERY KEPT DIEING, BUT THIS WAS OBVIOUSLY NOT THE PROBLEM. UPON INVESTIGATING "SIMILAR" PROBLEMS WITH ALMOST EVERY OTHER SUZUKI MOTORCYCLE, THE PROBLEM IS THE RECTIFIER AND AT A REPLACEMENT COST OF $ 235.00 WITHOUT LABOR, THIS IS UNBELIEVABLE ! I DON'T UNDERSTAND WHY THE M109R WASN'T INCLUDED IN THE RECALL AS I AND MANY OTHER M109R OWNERS ARE QUESTIONING IS A KNOWN DEFECT. *TR

TL* THE CONTACT OWNS A 2006 SUZUKI FORENZA. THE CONTACT STATED THAT WHILE STOPPED AT A STOP LIGHT, THE VEHICLE WOULD NOT ACCELERATE. THE FAILURE OCCURRED AT DIFFERENT SPEEDS INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC STATED THAT THE TRANSMISSION RANGE SENSOR WOULD HAVE TO BE REPLACED. THE CONTACT ALSO STATED THAT THE SAME PART WAS REPLACED TWO YEARS PRIOR TO OWNING THE VEHICLE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

I HAVE HAD NUMEROUS ISSUES WITH THE RANGE SWITCH IN MY 2007 SUZUKI FORENZA. THE FIRST TIME AT APPROXIMATELY 38K MILES, AND NOW AGAIN AT APPROXIMATELY 70K MILES. EACH TIME I'VE HAD THIS FIXED, IT HAS COST ME OVER $200. SUZUKI CUSTOMER SERVICE REFUSES TO ACKNOWLEDGE THIS AS A DEFECT, AND CONTINUES TO TAKE MONEY FROM THEIR CLIENTS WHO PURCHASED FAULTY VEHICLES. *TR

AIR BAG LIGHT STAYS ON HAD AUTO TO SUZUKI DEALER 3 TIME. LIGHT STILL ON THEY CHANGED CONTROL MODEL, SEAT SENSOR. I AM NOT THE ONLY ONE WITH THIS PROBLEM. THE CAR WAS NEVER WRECKED OR ANY DAMAGE TO IT. THEY ARE ORDERING A CLOCK SPRING WHICH I THINK IS WHOLE AIR BAG SYSTEM, I HAVE PAID 3200.00 DOLLARS WITH THE AIR BAG LIGHT THAT IS STILL ON. *TR

TL* THE CONTACT OWNS A 2007 SUZUKI SX4. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG AND SEAT BELT WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS ADVISED THAT THE CUSHION FOR THE PASSENGER SEAT NEEDED TO BE REPLACED BECAUSE THE SENSOR FAILED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 56,000 AND THE CURRENT MILEAGE WAS 56,200.

"AIRBAG" LIGHT ON AND CLOCK/TEMP DISPLAY FLASHES. THIS SYMPTOM WAS REPORTED TO SUZUKI MOTORS USA AS A SAFETY CONCERN SOON AFTER THE VEHICLE BEGAN SELLING BECAUSE THE FRONT PASSENGER SIDE AIRBAG MIGHT NOT DEPLOY IN CASE OF AN ACCIDENT. SUZUKI MOTORS USA ACKNOWLEDGED THE PROBLEM AND MADE AVAILABLE A NEW "ADJUSTER SET FRONT RIGHT" FOR REPLACEMENT. SUZUKI MOTORS WILL NOT REPLACE THE BAD COMPONENT, IT IS REQUIRING CUSTOMERS TO PAY THE 1HR LABOR + $1500 PART COST FOR VEHICLES THAT ARE PAST THE FACTORY WARRANTY (36 MONTHS, 100K MILES). THE COST TO CORRECT THE SAFETY PROBLEM SHOULD BE PAID SUZUKI MOTORS USA. *TR

ESP LIGHT CAME ON, BROUGHT TRUCK TO DEALER, THEY SAY IT HAS A BAD HYDRAULIC BRAKE UNIT AT THE COST OF $1200, SUZUKI WON'T FIX IT EVEN THOUGH THEIR IS ONLY 15101MI ON VEHICLE. MOUSE INFESTATION DUE TO POOR DESIGN OF CABIN BODY VENTS LOCATED BEHIND REAR BUMPER COVER. THERE ARE NO GRILLS IN PLACE OVER THESE VENTS TO KEEP RODENTS OUT, THEY INFESTED THE TRUCK AND HEADLINER AREA URINATING ALL OVER THE CURTAIN AIR BAGS AND COMPROMISED THEM, I CALLED SUZUKI AND BASICALLY WAS TOLD I'M THE ONLY ONE IN THE WORLD THIS HAPPENED TO AND BASICALLY DID NOTHING, $4000 IN DAMAGE. *TR